Abstract:Selectivity is the key parameter in industrial ethylene oxide (EO) production by oxidation of ethylene with oxygen on Ag/α–Al2O3 catalysts. Accurate temperature control in wall-cooled multitubular fixed-bed reactors and chlorination of the silver surface by feeding small chlorinated hydrocarbons such as 1,2-dichloroethane (DCE) are required to fine-tune electrophilicity and surface oxygen coverage for maximum EO selectivity at economic ethylene conversion. Temperature and molar flow rate profiles of C2H4, O2, EO, CO2, H2O, DCE, and chlorine-containing reaction products vinyl chloride (VC) and ethyl chloride (EC) were measured in a compact profile reactor (CPR) and in a pilot-scale profile reactor (PSPR) to explore the spatial interplay between DCE concentration, temperature, inlet flow rate, and O2 conversion. Chlorine and oxygen compete for the same active silver sites despite more than 4 orders of magnitude different concentrations (ppm vs vol %). Chlorine coverage increases from inlet to outlet due to the decreasing partial pressure of O2 along the bed, leading to shutdown of all reactions if all active Ag sites are blocked by chlorine. A kinetic model is derived from a dual-site mechanism taken from the literature. Kinetic parameters are determined from differential initial rate measurements, Arrhenius plots, and by fitting the rate expressions implemented in a plug flow model to the species and temperature profiles in the CPR. A very good agreement is reached. PSPR profiles are modeled by implementing the derived kinetic model into a 2D pseudohomogeneous reactor model. At conversions <10%, the experimental profiles are well captured, but the model fails to accurately reproduce the point of thermal runaway in the catalyst bed of the PSPR caused by a too low reactor temperature and resulting insufficient chlorine coverage of the silver surface.

Reaction gas induced activity enhancement for silver catalyst in ethylene epoxidation

Tailoring the Electronic Metal‐Support Interactions in Supported Silver Catalysts through Al modification for Efficient Ethylene Epoxidation

Increased Silver Activity For Direct Propylene Epoxidation Via Subnanometer Size Effects

Square-pyramidal Subsurface Oxygen [ag4oag] Drives Selective Ethene Epoxidation on Silver

Revealing the Nature of Active Oxygen Species and Reaction Mechanism of Ethylene Epoxidation by Supported Ag/α-Al2O3 Catalysts

Revealing the Nature of Active Oxygen Species and Reaction Mechanism of Ethylene Epoxidation by Supported Ag/α-Al 2 O 3 Catalysts

Stability enhancement for silver catalyst in ethylene epoxidation by support treatment

Cs-promoted Active Species for Ag-catalyzed Ethylene Epoxidation

Overview of Selective Oxidation of Ethylene to Ethylene Oxide by Ag Catalysts

Study on Ag-Mo Catalyst for Direct Vapor-Phase Epoxidation of Propylene by Molecular Oxygen

Enhanced catalytic oxidation of diluted ethylene oxide on Pt/CeO<sub>2</sub> catalyst under low temperature

Understanding Trends in Ethylene Epoxidation on Group IB Metals

Revealing Activity of Symmetrical and Asymmetrical Ag2O‐MOx (M = Cu, Fe, Zn) Catalysts via DFT Calculations for Direct Propylene Epoxidation

Nature and Reactivity of Oxygen Species On/in Silver Catalysts During Ethylene Oxidation

Promotional Effect of Y2O3 on the Performance of Ag/α-Al2O3 Catalyst for Epoxidation of Propylene with Molecular Oxygen

Epoxidation of Propylene by Molecular Oxygen over the Ag–Y2O3–K2O/α-Al2O3 Catalyst

Selective Oxidation of Ethylene to Ethylene Oxide on Silver Catalysts at Industrial Conditions: Reactor Profiles, Kinetics, and Chlorine Inhibition

Role of Chlorohydrocarbon in Increasing Selectivity of Propylene Oxide over Ag–Y2O3–K2O/α-Al2O3 Catalyst for Epoxidation of Propylene by Molecular Oxygen

Rapid Absorption of Ethylene Oxide Exhaust by Catalytic Hydration on Acid Zeolite Catalysts

Direct epoxidation of propylene by molecular oxygen over Y2O3 and K2O-promoted Ag/α-Al2O3 catalyst

High-Loading Single-Atomic-Site Silver Catalysts with an Ag1–C2N1 Structure Showing Superior Performance for Epoxidation of Styrene