Abstract:Raised temperature polyethylene (PE-RT) is being studied for use in the conveyancing of sour hydrocarbon fluids in spoolable composite pipe at temperatures above 90 °C. This grade of polyethylene swells on exposure to all hydrocarbons but specifically aromatic hydrocarbons and so there is a requirement to reduce the flux of hydrocarbons and gases into the base PE-RT. A multi-material pipe wall is one solution to reduce these fluxes but new experimental methods are required for design and validation while saturated in sour hydrocarbon fluids. In this study the simultaneous transport of species such as CO 2 , H 2 S, CH 4, water vapour and aromatic hydrocarbon vapours such as toluene, xylene, IRM902 and cyclohexane were measured in real time through single films of PVDF and PE-RT and multilayer walls of PVDF/tie layer(s)/PE-RT extracted from a built (co-extruded) pipe section. The permeation test facility contained specialized gas chromatographs modified for continuous quantification of all species. The experimental methods were designed to run at 93 °C with gas pressures of 104 barg or 250 barg. Experiments were run with gas only mixtures (dry tests) and also with gas cap above a mixture of liquid hydrocarbons and water (wet tests). When possible, transport properties such as diffusion and solubility coefficients were derived from the permeation traces. The volume flow rate of all species was higher through PE-RT compared to PVDF and the volume flow rate for CO 2 , H 2 S, and CH 4, increased when the gas pressure was increased from 104 to 250 barg. The gas permeability was calculated for the base polymers and also the combined multilayer structure. The flow rates estimated for a multilayer specimen using the values measured on individual films were confirmed experimentally. A simple mathematical model was proposed to derive the apparent permeability of the multilayer system and the steady-state concentration profiles across the specimen wall. Specimens were inspected for damage after a final depressurization at 70 bargmin −1 . Post exposure assessment of the laminates showed that the adhesion levels were improved and the failure mode was altered from adhesive to cohesive on ageing.

Review of Developed Methods for Measuring Gas Uptake and Diffusivity in Polymers Enriched by Pure Gas under High Pressure

Recent Progress on Submicron Gas-Selective Polymeric Membranes

Investigation of the Gas Permeation Properties Using the Volumetric Analysis Technique for Polyethylene Materials Enriched with Pure Gases under High Pressure: H2, He, N2, O2 and Ar

Diffusion measurements of isopentane, 1-hexene, cyclohexane in polyethylene particles by the intelligent gravimetric analyzer

Accurate measurement of micro gas flow rates for comprehensive evaluation of polymeric membranes applicable in gaseous separations

Measurement of Reactive and Condensable Gas Permeation Using a Mass Spectrometer

Multi-lab Study on the Pure-Gas Permeation of Commercial Polysulfone (psf) Membranes: Measurement Standards and Best Practices

In Situ Changes in Mechanical Properties Based on Gas Saturation Inside Pressure Vessels

Gas Transport in Mixed Matrix Membranes: Two Methods for Time Lag Determination

The Development of Gas Sensitive Polymer and Polymer Composite

Correlations between H2 Permeation and Physical/Mechanical Properties in Ethylene Propylene Diene Monomer Polymers Blended with Carbon Black and Silica Fillers

Comparison of Two Methods for Measuring the Temperature Dependence of H2 Permeation Parameters in Nitrile Butadiene Rubber Polymer Composites Blended with Fillers: The Volumetric Analysis Method and the Differential Pressure Method

Permeance of Condensable Gases in Rubbery Polymer Membranes at High Pressure

Examining differences in the uptake of corrosive gases in polymer films and its dependence on temperature and relative humidity using a novel procedure combining sample weathering and LA-ICP-MS analysis

A Review of Methodologies for the Rapid Analysis and Quantification of Gases in Solid Media

Kinetic gravimetric sorption of low volatility gases and vapors in polymers

Reduction in the transport of sour gases and hydrocarbons to underlying PE-RT through thin films of PVDF

Recent Progress in Microporous Polymers from Thermally Rearranged Polymers and Polymers of Intrinsic Microporosity for Membrane Gas Separation: Pushing Performance Limits and Revisiting Trade‐off Lines

Measurement of Solubility Thermodynamic and Diffusion Kinetic Characteristic of Solvents in PDMS by Inverse Gas Chromatography

Concrete Gas Permeability from Different Methods: Correlation Analysis

Comparison of permeation of atmospheric gases through Viton O-ring gaskets for different initial conditions