Abstract:Developing efficient supports for transition-metal nanoparticles (M-NPs) to prevent their agglomeration and to facilitate their handling and recycled use has been a constant objective. Herein, porous polyurea (PPU) is prepared by simple precipitation polymerization of toluene diisocyanate through its reaction with water in water–acetone, followed by Pd(OAc)2 immobilization on a PPU surface to get Pd(OAc)2@PPU and by Pd(OAc)2 reduction to get a hybrid composite with Pd-NPs on a PPU surface. Multiple characterizations revealed that the porous structure of PPU was retained in Pd(OAc)2@PPU and Pd NPs were well dispersed on the surface with a mean diameter of 7.18 nm. was used as catalyst for reduction of toxic hexavalent chromium Cr(VI) to benign trivalent chromium with formic acid as the reducer. A higher catalytic performance was detected compared to that of reported heterogeneous catalysts under similar conditions. A slight decrease in catalytic activity was detected in recycled use of the catalyst, which is ascribed to CO poisoning, a byproduct in formic acid decomposition. Full regeneration was obtained by heating the catalyst under N2 atmosphere for 2 h at 180 °C. This work provides therefore a novel approach for the preparation of a catalyst of high performance for Cr(VI) reduction, featured by low cost, facile synthesis, easy handling, and reusability.The Supporting Information is available free of charge at <a class="ext-link" href="/doi/10.1021/acs.iecr.1c01376?goto=supporting-info">https://pubs.acs.org/doi/10.1021/acs.iecr.1c01376</a>.Experimental section; UV–vis absorbance spectra of Pd(OAc)2 solution, Pd(OAc)2 loading rate, and Pd(II) loaded on PPU; XRD diffractograms, FTIR and 13C NMR spectra of PPU, Pd(OAc)2@PPU, and ; TEM images of and ; sizes of Pd-NPs in ; UV–vis absorbance of supernatant in Cr(VI) reduction with replaced by Pd(OAc)2@PPU, and those in the presence of without FA; UV–vis spectra and pH of K2Cr2O7 solution in the presence of different chemicals; reduction of Cr(VI) with different initial concentrations; gas generated by dehydrogenation of FA; chemisorption results of Pd-NPs in and ; reusability of in Cr(VI) reduction; test of Pd leaching from ; XRD diffractograms and TEM images of after six recycled uses and that of the regenerated; UV–vis spectra in Cr(VI) reduction with pretreated with H2, CO2, and CO; catalytic activity of regenerated at different time.This article has not yet been cited by other publications.

Preparation of Pd/MnO2 catalyst and its catalytic hydrogenation reduction of Cr(VI)

Synthesis of Pd/(MnO2@PANI) Catalyst and Its Study on the Reduction of Cr(VI)

Liquid Phase Catalytic Hydrogenation Reduction of Cr(VI) Using Highly Stable and Active Pd/CNT Catalysts Coated by N-doped Carbon.

Effective catalytic reduction of Cr(VI) over TiO2 nanotube supported Pd catalysts

Influence of Preparation Condition on the PdHx Phase of Pd/C Catalyst

Preparation and Catalytic Performance of Metal-Rich Pd Phosphides for the Solvent-Free Selective Hydrogenation of Chloronitrobenzene

Cr(Ⅵ) REDUCTION BY CATALYTIC HYDROGENATION WITH Pd/Al_2O_3 CATALYSTS

Pd sub-nanolayer on Au core for enhanced catalytic hydrogenation reduction of oxyanions pollutants: Synergistic effect of Pd and Au

Palladium nanoparticles supported on aluminum oxide (Al2O3) for the catalytic hexavalent chromium reduction

A Facile Route for Spraying Preparation of Pt/TiO2 Monolithic Catalysts Toward VOCs Combustion

Stable Incorporation of MnOx Quantum Dots into N-doped Hollow Carbon: A Synergistic Peroxymonosulfate Activator for Enhanced Removal of Bisphenol A

Porous Polyurea Supported Pd Catalyst: Easy Preparation, Full Characterization, and High Activity and Reusability in Reduction of Hexavalent Chromium in Aqueous System

Amino-functionalized graphene oxide-supported networked Pd–Ag nanowires as highly efficient catalyst for reducing Cr(VI) in industrial effluent by formic acid

CO2 hydrogenation to methanol over Pd/MnO/In2O3 catalyst

Accelerating Catalytic Oxyanion Reduction with Inert Metal Hydroxides

Palladium Nanoparticles Uniformly and Firmly Supported on Hierarchical Flower-Like TiO2 Nanospheres As a Highly Active and Reusable Catalyst for Detoxification of Cr(VI)-contaminated Water

Efficient hydrogenation of p-chlorophenol and Cr(VI) driven by hydrogen rich balls over Pd/C catalysts

Reduction and removal of Cr(VI) in water using biosynthesized palladium nanoparticles loaded Shewanella oneidensis MR-1

Optimizing Cr(VI) reduction to Cr(III) using Pd-CNTs nanocatalyst: kinetic Monte Carlo simulation and experimental design insights

MnO2 Enhances Electrocatalytic Hydrodechlorination by Pd/Ni Foam Electrodes and Reduces Pd Needs

Optimizing electronic states of Pd/WO 3 nanofibers for enhanced catalytic reduction of hexavalent chromium with formic acid