Abstract:Developing efficient supports for transition-metal nanoparticles (M-NPs) to prevent their agglomeration and to facilitate their handling and recycled use has been a constant objective. Herein, porous polyurea (PPU) is prepared by simple precipitation polymerization of toluene diisocyanate through its reaction with water in water–acetone, followed by Pd(OAc)2 immobilization on a PPU surface to get Pd(OAc)2@PPU and by Pd(OAc)2 reduction to get a hybrid composite with Pd-NPs on a PPU surface. Multiple characterizations revealed that the porous structure of PPU was retained in Pd(OAc)2@PPU and Pd NPs were well dispersed on the surface with a mean diameter of 7.18 nm. was used as catalyst for reduction of toxic hexavalent chromium Cr(VI) to benign trivalent chromium with formic acid as the reducer. A higher catalytic performance was detected compared to that of reported heterogeneous catalysts under similar conditions. A slight decrease in catalytic activity was detected in recycled use of the catalyst, which is ascribed to CO poisoning, a byproduct in formic acid decomposition. Full regeneration was obtained by heating the catalyst under N2 atmosphere for 2 h at 180 °C. This work provides therefore a novel approach for the preparation of a catalyst of high performance for Cr(VI) reduction, featured by low cost, facile synthesis, easy handling, and reusability.The Supporting Information is available free of charge at <a class="ext-link" href="/doi/10.1021/acs.iecr.1c01376?goto=supporting-info">https://pubs.acs.org/doi/10.1021/acs.iecr.1c01376</a>.Experimental section; UV–vis absorbance spectra of Pd(OAc)2 solution, Pd(OAc)2 loading rate, and Pd(II) loaded on PPU; XRD diffractograms, FTIR and 13C NMR spectra of PPU, Pd(OAc)2@PPU, and ; TEM images of and ; sizes of Pd-NPs in ; UV–vis absorbance of supernatant in Cr(VI) reduction with replaced by Pd(OAc)2@PPU, and those in the presence of without FA; UV–vis spectra and pH of K2Cr2O7 solution in the presence of different chemicals; reduction of Cr(VI) with different initial concentrations; gas generated by dehydrogenation of FA; chemisorption results of Pd-NPs in and ; reusability of in Cr(VI) reduction; test of Pd leaching from ; XRD diffractograms and TEM images of after six recycled uses and that of the regenerated; UV–vis spectra in Cr(VI) reduction with pretreated with H2, CO2, and CO; catalytic activity of regenerated at different time.This article has not yet been cited by other publications.

Palladium Nanoparticles Uniformly and Firmly Supported on Hierarchical Flower-Like TiO2 Nanospheres As a Highly Active and Reusable Catalyst for Detoxification of Cr(VI)-contaminated Water

Reclamation of hexavalent chromium using catalytic activity of highly recyclable biogenic Pd(0) nanoparticles

Modulation of titania nanoflower arrays transformed from titanate nanowire arrays to boost photocatalytic Cr(vi) detoxification

Fabrication of Ti-PDA nanoparticles with enhanced absorption and photocatalytic activities for hexavalent chromium Cr(VI) removal

Liquid Phase Catalytic Hydrogenation Reduction of Cr(VI) Using Highly Stable and Active Pd/CNT Catalysts Coated by N-doped Carbon.

Porous Polyurea Supported Pd Catalyst: Easy Preparation, Full Characterization, and High Activity and Reusability in Reduction of Hexavalent Chromium in Aqueous System

Effective catalytic reduction of Cr(VI) over TiO2 nanotube supported Pd catalysts

Palladium nanoparticles supported on aluminum oxide (Al2O3) for the catalytic hexavalent chromium reduction

Rapid and efficient reduction of chromate by novel Pd/Fe@biomass derived from Enterococcus faecalis

Removal of Hexavalent Chromium from Wastewater by Cu/Fe Bimetallic Nanoparticles

Reduction of Hexavalent Chromium with Colloidal and Supported Palladium Nanocatalysts

Photocatalytic removal of hexavalent chromium by newly designed and highly reductive TiO2 nanocrystals.

Porous carbon nanofiber/porphyrin-based metal organic frameworks/TiO 2 nanoparticles ternary materials for selective detection and photoreduction of Cr(VI)

Optimizing electronic states of Pd/WO 3 nanofibers for enhanced catalytic reduction of hexavalent chromium with formic acid

Facile Synthesis of Nitrogen-Doped Carbon Coated Fe3O4/Pd Nanoparticles As a High-Performance Catalyst for Cr (VI) Reduction

Detoxification of groundwater contaminated with Cr(VI) using continuous electrochemical cell equipped with copper foam electrode modified with palladium nanoparticles

Pd sub-nanolayer on Au core for enhanced catalytic hydrogenation reduction of oxyanions pollutants: Synergistic effect of Pd and Au

Synthesis of Pd/(MnO2@PANI) Catalyst and Its Study on the Reduction of Cr(VI)

Bimetallic FeNi Nanoparticles Immobilized by Biomass-Derived Hierarchically Porous Carbon for Efficient Removal of Cr(VI) from Aqueous Solution

Reduction and removal of Cr(VI) in water using biosynthesized palladium nanoparticles loaded Shewanella oneidensis MR-1

Enhanced photocatalytic reduction of Cr(VI) from aqueous solution using Fe0/TiO2-based polymeric nanocomposites