Abstract:In this article, domain wall motion and the extrinsic contributions to the dielectric and piezoelectric responses in sol–gel derived lead zirconate titanate (PZT) films with compositions near the morphotropic phase boundary were investigated. It was found that although the films had different thicknesses, grain sizes, and preferred orientations, similar intrinsic dielectric constants were obtained for all films between 0.5 and 3.4 μm thick. It was estimated that about 25%–50% of the dielectric response at room temperature was from extrinsic sources. The extrinsic contribution to the dielectric constant of PZT films was mainly attributed to 180° domain wall motion, which increased with both film thickness and grain size. In studies on the direct and converse longitudinal piezoelectric coefficients of PZT films as a function of either stress or electric driving field, it was found that the ferroelastic non-180° domain wall motion was limited. Thus extrinsic contributions to the piezoelectric response were small in fine grain PZT films (especially those under 1.5 μm in thickness). However, as the films became thicker (>5μm), nonlinear behavior between the converse piezoelectric coefficient and the electric driving field was observed. This indicated that there was significant ferroelectric non-180° domain wall motion under high external excitation in thicker films. The activity of the non-180° domain walls was studied through non-180° domain switching. For fine grain films with film thicknesses less than 2 μm, non-180° switching was negligible. Transmission electron microscopy plan-view micrographs evidenced non-180° domain fringes in these films, where the vast majority of grains were 50–100 nm in diameter and showed a single set of domain fringes. Taken together, these measurements suggest that the pinning of non-180° domain walls is very strong in films with thickness less than 2 μm. In thicker films, non-180° domain switching was evidenced when the poling field exceeded a threshold field. The threshold field decreased with an increase in film thickness, suggesting more non-180° domain wall mobility in thicker films. Non-180° domain switching in large grained PZT films was found to be much easier and more significant than in the fine grained PZT films.

Piezoelectrics: Influence of a Single Grain Boundary on Domain Wall Motion in Ferroelectrics (Adv. Funct. Mater. 10/2014)

Effect Of Grain Boundary On The Electromechanical Response Of Ferroelectric Polycrystals

Domain wall-grain boundary interactions in polycrystalline Pb(Zr0.7Ti0.3)O3 piezoceramics

Mapping domain structures near a grain boundary in a lead zirconate titanate ferroelectric film using X‐ray nanodiffraction

Phase Field Simulations of the Poling Process and Nonlinear Behavior of Ferroelectric Polycrystals with Semiconducting Grain Boundaries

Domain Wall Motion and Its Contribution to the Dielectric and Piezoelectric Properties of Lead Zirconate Titanate Films

Ferroelectric Domain Wall Pinning at A Bicrystal Grain Boundary in Bismuth Ferrite

Effect Of Grain Size On The Domain Structures And Electromechanical Responses Of Ferroelectric Polycrystal

Electromechanical nonlinearity of ferroelectric ceramics and related non-180° domain wall motions

Reversible Domain-Wall-Motion-Induced Low-Hysteretic Piezoelectric Response in Ferroelectrics

Domain wall architecture in tetragonal ferroelectric thin films

Quantitative piezoelectric force microscopy: Influence of tip shape, size, and contact geometry on the nanoscale resolution of an antiparallel ferroelectric domain wall

Direct Measurement of Piezoelectric Response around Ferroelectric Domain Walls in Crystals with Engineered Domain Configuration

Effects of Domain Wall Proximity on Nanoscale Polarization Switching in Relaxor‐Ferroelectric Single Crystals

Inspecting Piezoelectricity in PbZr1−x Ti X O3 Single Crystals with Ferroelastic Domains

Dynamics and Manipulation of Ferroelectric Domain Walls in Bismuth Ferrite Thin Films.

Electromechanical coupling among edge dislocations, domain walls, and nanodomains in BiFeO3 revealed by unit-cell-wise strain and polarization maps

Understanding the Grain Size Dependence of Functionalities in Lead-Free (Ba,ca)(zr,ti)o3

Reduction of the lattice strain with increasing field amplitude in polycrystalline BiFeO 3

Unraveling Deterministic Mesoscopic Polarization Switching Mechanisms: Spatially Resolved Studies of a Tilt Grain Boundary in Bismuth Ferrite

Probing the Intrinsic and Extrinsic Origins of Piezoelectricity in Lead Zirconate Titanate Single Crystals