Abstract:Properties of unintentionally-doped GaN re-grown on molecular beam epitaxy grown AlN/Sapphire templates by metal organic vapor phase epitaxy (MOVPE) are studied in this article. X-ray diffraction (XRD), transmission electron microscope (TEM), and atomic force microscope are used to investigate the influence of the crystal quality and surface morphology of AlN on the GaN. It is found that when surface roughness of AlN is small, the GaN has a full width at half maximum (FWHM) values of XRD rocking curves (200—300 and 400—500 arcsec for (002) and (102) plane ω-scan, respectively) and surface roughness (0.1—0.2 nm), which are comparable to those grown on sapphire substrates by using "two-step" method, although the FWHMs of (102) plane XRD ω-scan curves of AlN are 900—1500 arcsec. The reason for dislocation reduction in GaN shown by TEM image is that a part of dislocations in AlN are eliminated in the interface between AlN and GaN. This is probably due to the lattice restoration from Ga atoms for their large size. On the other hand, when surface roughness of AlN is large, the surface migration of Ga atoms is nestricted during the MOVPE growth, which results in a poor GaN quality. Moreover, the resistivity of GaN confirmed with Van der Pauw method is between 105 and 106 Ω ·cm, which is about six orders of magnitude higher than that in GaN grown on sapphire substrates. This is attributed to the replacement of low temperature GaN buffer layer by the AlN.

Improved nucleation of AlN on in situ nitrogen doped graphene for GaN quasi-van der Waals epitaxy

Growth of High Quality AlN on Sapphire with Multi-Growth Approaches

High-quality GaN grown on nitrogen-doped monolayer graphene without an intermediate layer

Investigation of GaN with Low Threading Dislocation Density Grown on Graphene/Sputtered AlN Composite Substrate

Enhancing two-dimensional growth of high-temperature AlN buffer to improve the quality of GaN on Si grown by ex situ two-step method

Graphene-assisted growth of high-quality AlN by metalorganic chemical vapor deposition

Flexible graphene-assisted van der Waals epitaxy growth of crack-free AlN epilayer on SiC by lattice engineering

Gan Grown on Ain/Sapphire Templates

Epitaxial AlN film with improved quality on Si (111) substrates realized by boron pretreatment via MOCVD

Study on AlN Buffer Layer for GaN on Graphene/copper Sheet Grown by MBE at Low Growth Temperature

Effect of AlN nucleation layer thickness on the quality of GaN grown on Si(111)

Low-temperaturevan Der Waals Epitaxy of GaN Films on Graphene Through AlN Buffer by Plasma-Assisted Molecular Beam Epitaxy

Epitaxial Growth Mechanisms of Single-Crystalline GaN on Single-Crystalline Graphene

Improved Epitaxy of AlN Film for Deep‐Ultraviolet Light‐Emitting Diodes Enabled by Graphene

Graphene-Assisted Quasi-van der Waals Epitaxy of AlN Film on Nano-Patterned Sapphire Substrate for Ultraviolet Light Emitting Diodes

High Quality AlN Epilayers Grown on Nitrided Sapphire by Metal Organic Chemical Vapor Deposition

Graphene-assisted quasi-van der Waals epitaxy of AlN film for ultraviolet light emitting diodes on nano-patterned sapphire substrate

The influence of an AlN seeding layer on nucleation of self-assembled GaN nanowires on silicon substrates

Improved crystal quality of AlGaN by Al ion-implantation sapphire substrate

Effect of initial condition on the quality of GaN film and AlGaN/GaN heterojunction grown on flat sapphire substrate with ex-situ sputtered AlN by MOCVD