Abstract:An innovative approach has been recently proposed in order to link polyhydroxyalkanoates (PHA) production with sludge minimization in municipal wastewater treatment, where (1) a sequencing batch reactor (SBR) is used for the simultaneous municipal wastewater treatment and the selection/enrichment of biomass with storage ability and (2) the acidogenic fermentation of the primary sludge is used to produce a stream rich in volatile fatty acids (VFAs) as the carbon source for the following PHA accumulation stage. The reliability of the proposed process has been evaluated at lab scale by using substrate synthetic mixtures for both stages, simulating a low-strength municipal wastewater and the effluent from primary sludge fermentation, respectively. Six SBR runs were performed under the same operating conditions, each time starting from a new activated sludge inoculum. In every SBR run, despite the low VFA content (10 % chemical oxygen demand, COD basis) of the substrate synthetic mixture, a stable feast–famine regime was established, ensuring the necessary selection/enrichment of the sludge and soluble COD removal to 89 %. A good process reproducibility was observed, as also confirmed by denaturing gradient gel electrophoresis (DGGE) analysis of the microbial community, which showed that a high similarity after SBR steady-state had been reached. The main variation factors of the storage properties among different runs were uncontrolled changes of settling properties which in turn caused variations of both sludge retention time and specific organic loading rate. In the following accumulation batch tests, the selected/enriched consortium was able to accumulate PHA with good rate (63 mg CODPHA g CODXa−1 h−1) and yield (0.23 CODPHA CODΔS−1) in spite that the feeding solution was different from the acclimation one. Even though the PHA production performance still requires optimization, the proposed process has a good potential especially if coupled to minimization of both primary sludge (by its use as the VFA source for the PHA accumulation, via previous fermentation) and excess secondary sludge (by its use as the biomass source for the PHA accumulation).

Visualization of Polyhydroxyalkanoate Accumulated in Waste Activated Sludge

Exploring the Limits of Polyhydroxyalkanoate Production by Municipal Activated Sludge

Coupling of Polyhydroxyalkanoate Production with Volatile Fatty Acid from Food Wastes and Excess Sludge

Polyhydroxyalkanoate (PHA) production in open mixed cultures using waste activated sludge as biomass

Effect of culture history and carbon sources on polyhydroxyalkanoates production in activated sludge systems

Process conditions affect properties and outcomes of polyhydroxyalkanoate accumulation in municipal activated sludge

Bioplastic polyhydroxyalkanoate conversion in waste activated sludge

Production of polyhydroxyalkanoates by activated sludge: Correlation with extracellular polymeric substances and characteristics of activated sludge

Evaluation and optimization of FTIR spectroscopy to quantify PHA production by municipal wastewater sludge

Consistent production of high quality PHA using activated sludge harvested from full scale municipal wastewater treatment - PHARIO

Polyhydroxyalkanoate production from fermented volatile fatty acids: effect of pH and feeding regimes.

Biosynthesis of Polyhydroxyalkanoates (PHAs) by the Valorization of Biomass and Synthetic Waste

Genome-centric metagenomics provides new insights into metabolic pathways of polyhydroxyalkanoates biosynthesis and functional microorganisms subsisting on municipal organic wastes

Production of Polyhydroxyalkanoates (PHA) by Bacterial Consortium from Excess Sludge Fermentation Liquid at Laboratory and Pilot Scales

Three-dimensional label-free visualization and quantification of polyhydroxyalkanoates in individual bacterial cell in its native state

Calcium enhances polyhydroxyalkanoate production and promotes selective growth of the polyhydroxyalkanoate-storing biomass in municipal activated sludge

Sludge minimization in municipal wastewater treatment by polyhydroxyalkanoate (PHA) production

Effect of composition of volatile fatty acids on yield of polyhydroxyalkanoates and mechanisms of bioconversion from activated sludge

Polyhydroxyalkanoates production by Ralstonia eutropha H16 fed by waste sludge anaerobic fermentative liquid

Polyhydroxyalkanoates (PHA) Production from Fermented Thermal-Hydrolyzed Sludge by PHA-storing Denitrifiers Integrating PHA Accumulation with Nitrate Removal.

Optimization of an enriched mixed culture to increase PHA accumulation using industrial saline complex wastewater as a substrate