Abstract:An innovative approach has been recently proposed in order to link polyhydroxyalkanoates (PHA) production with sludge minimization in municipal wastewater treatment, where (1) a sequencing batch reactor (SBR) is used for the simultaneous municipal wastewater treatment and the selection/enrichment of biomass with storage ability and (2) the acidogenic fermentation of the primary sludge is used to produce a stream rich in volatile fatty acids (VFAs) as the carbon source for the following PHA accumulation stage. The reliability of the proposed process has been evaluated at lab scale by using substrate synthetic mixtures for both stages, simulating a low-strength municipal wastewater and the effluent from primary sludge fermentation, respectively. Six SBR runs were performed under the same operating conditions, each time starting from a new activated sludge inoculum. In every SBR run, despite the low VFA content (10 % chemical oxygen demand, COD basis) of the substrate synthetic mixture, a stable feast–famine regime was established, ensuring the necessary selection/enrichment of the sludge and soluble COD removal to 89 %. A good process reproducibility was observed, as also confirmed by denaturing gradient gel electrophoresis (DGGE) analysis of the microbial community, which showed that a high similarity after SBR steady-state had been reached. The main variation factors of the storage properties among different runs were uncontrolled changes of settling properties which in turn caused variations of both sludge retention time and specific organic loading rate. In the following accumulation batch tests, the selected/enriched consortium was able to accumulate PHA with good rate (63 mg CODPHA g CODXa−1 h−1) and yield (0.23 CODPHA CODΔS−1) in spite that the feeding solution was different from the acclimation one. Even though the PHA production performance still requires optimization, the proposed process has a good potential especially if coupled to minimization of both primary sludge (by its use as the VFA source for the PHA accumulation, via previous fermentation) and excess secondary sludge (by its use as the biomass source for the PHA accumulation).

Bioplastic polyhydroxyalkanoate conversion in waste activated sludge

Towards scaling-up implementation of polyhydroxyalkanoate (PHA) production from activated sludge: Progress and challenges

Biowaste-to-bioplastic (polyhydroxyalkanoates): Conversion technologies, strategies, challenges, and perspective

Coupling of Polyhydroxyalkanoate Production with Volatile Fatty Acid from Food Wastes and Excess Sludge

Bio-conversion of organic wastes towards polyhydroxyalkanoates

[The Degradation of Plastics and the Production of Polyhydroxyalkanoates (PHA)].

A review on polyhydroxyalkanoates production from various organic waste streams: Feedstocks, strains, and production strategy

Production of bioplastic through food waste valorization

Comprehensive Techno-environmental Evaluation of a Pilot-Scale PHA Production from Food Waste in China

A review on polyhydroxyalkanoate production from agricultural waste Biomass: Development, Advances, circular Approach, and challenges

A review on microbes mediated resource recovery and bioplastic (polyhydroxyalkanoates) production from wastewater

Recent Advances in polyhydroxyalkanoates production by mixed cultures

Current status and future perspectives on the biological production of polyhydroxyalkanoates

Sludge minimization in municipal wastewater treatment by polyhydroxyalkanoate (PHA) production

Biosynthesis of Polyhydroxyalkanoates (PHAs) by the Valorization of Biomass and Synthetic Waste

From waste to wealth: upcycling of plastic and lignocellulosic wastes to PHAs

Effect of enrichment conditions of secondary feeding on the synthesis of polyhydroxyalkanoates (PHAs) by activated sludge

Current Status and Challenges in the Commercial Production of Polyhydroxyalkanoate-Based Bioplastic: A Review

Valorisation of Sugarcane Bagasse for the Sustainable Production of Polyhydroxyalkanoates

Polyhydroxyalkanoate (PHA) production in open mixed cultures using waste activated sludge as biomass

Effect of culture history and carbon sources on polyhydroxyalkanoates production in activated sludge systems