Abstract:Fused silica crucibles are commonly used in the fabrication process of solar grade silicon ingots. These crucibles are manufactured from high purity natural quartz sand and as a consequence, their properties are influenced by the presence of water and hydroxyls in the raw quartz. In this work, diffuse reflectance IR, 1H magic angle spinning NMR, and Raman spectroscopy were used to investigate the influence of thermal treatment on water and hydroxyl groups in high purity natural quartz sand. Most of the water in dry sand is present in the form of closed inclusions within the quartz grains which were detected in Raman imaging studies, even after thermally treating the samples at 600 °C. Only after heating to 900 °C did this water completely vanish, most likely as a result of rupturing of the inclusions. However, newly formed OH groups, identified as isolated and hydrogen bound OH were observed as products of the reaction between water and quartz. Similarly, liquid water was observed in NMR spectra even after treatment at 600 °C while at temperatures >900 °C, only non-interacting silanol groups were present. The comparison of the temperature dependence of the IR and NMR spectra also yields insight into the assignment of the OH stretching mode region of the IR spectrum in this system. The intensity of water related bands decreases while the intensity of OH bands first increases and then decreases with increasing temperature. The band intensity of Al-rich defects as well as the characteristic feature at 3200 cm-1 does not follow the temperature dependence of typical water peaks. It is also shown that leaching the quartz sand in HF solution helps to remove water from inclusions, likely by forming pathways for fluid flow inside the quartz grains. Milling of the samples caused formation of an additional type of hydroxyl group, possibly due to partial amorphisation of the surfaces of the quartz grains surface during the process. The results improve the basis for a knowledge-based processes development for the processing of high purity natural quartz.

High‐pressure torsion of SiO 2 quartz sand: Phase transformation, optical properties, and significance in geology

Advances in the study of phase transformation of silica under high pressure

Features and significance of amorphous SiO2 in the low-temperature and high-pressure micro-metamorphic body from Mulanshan, Hubei province

Pressure-induced Amorphization of Crystalline Silica

High-pressure Crystal Chemistry and Amorphization of Α-Quartz

Enhanced optical anisotropy of six-coordinated silica polymorphs via high-pressure hydrothermal treatment

Synchrotron X-Ray Diffraction of Sio2 to Multimegabar Pressures

Stability Limits and Transformation Pathways Ofα-Quartz under High Pressure

Pressure-induced Structural Modulations in Coesite

Structural Characteristics and Elasticities of Coesite and Coesite-Ii at High Pressure

High-pressure Raman spectroscopy study of α-quartz-like Si1-xGexO2 solid solution

Stress-dependent Transformation of Interstitial Oxygen in Processed Ge-doped Cz-Si

High-Temperature Raman-Spectroscopy Of Sio2 And Geo2 Polymorphs - Anharmonicity And Thermodynamic Properties At High-Temperatures

Phase Transformation in Nanocrystalline Alpha-Quartz Geo2 Up to 51.5 Gpa

Understanding phase transitions of $α$-quartz under dynamic compression conditions by machine-learning driven atomistic simulations

Pressure-Induced Drastic Collapse Of A High Oxygen Coordination Shell In Quartz-Like Alpha-Geo2

Structural evolution of water and hydroxyl groups during thermal, mechanical and chemical treatment of high purity natural quartz

Multiple Pathways in Pressure-Induced Phase Transition of Coesite.

Effect of High Temperature–pressure on Nitrogen-Doped Czochralski Silicon

Raman Spectroscopy of SiO2 Glass at High Pressure.

High-pressure Crystalline Transformations and Amorphization in Α-Quartz