Abstract:The direct integration of GaN with Si can boost great potential for low-cost, large-scale, and high-power device applications. However, it is still challengeable to directly grow GaN on Si without using thick strain relief buffer layers due to their large lattice and thermal-expansion-coefficient mismatches. In this work, a GaN/Si heterointerface without any buffer layer is fabricated at room temperature via surface activated bonding (SAB). The residual stress states and interfacial microstructures of GaN/Si heterostructures were systematically investigated through micro-Raman spectroscopy and transmission electron microscopy. Compared to the large compressive stress that existed in GaN layers grown on Si by metalorganic chemical vapor deposition, a significantly relaxed and uniform small tensile stress was observed in GaN layers bonded to Si by SAB; this is mainly ascribed to the amorphous layer formed at the bonding interface. In addition, the interfacial microstructure and stress states of bonded GaN/Si heterointerfaces was found to be significantly tuned by appropriate thermal annealing. With increasing annealing temperature, the amorphous interlayer formed at the as-bonded interface gradually transforms into a thin crystallized interlayer without any observable defects even after annealing at 1000 °C, while the interlayer stresses at both GaN layer and Si monotonically change due to the interfacial re-crystallization. This work moves an important step forward directly integrating GaN to the present Si CMOS technology with high quality thin interfaces and brings great promises for wafer-scale low-cost fabrication of GaN electronics.

Strain release in GaN epitaxy on 4° off‐axis 4H‐SiC

Strain Release in GaN Epitaxy on 4 degrees Off-Axis 4H-SiC

Multiphysics Simulation Study of Thermal Stress Effects in Nanoscale FinFETs Heterogeneously Integrated with GaN High-Power Device on Silicon Substrate

The Effect of Gan Single Crystal Substrate Characteristics on Homo-Epitaxial Gan Films

Development of GaN HEMTs Fabricated on Silicon, Silicon-on-Insulator, and Engineered Substrates and the Heterogeneous Integration

Anisotropic Strain Relaxation and High Quality AlGaN/GaN Heterostructures on Si (110) Substrates

HyFET—A GaN/SiC Hybrid Field-Effect Transistor

High Mobility Algan/Gan Heterostructures Grown on Si Substrates Using A Large Lattice-Mismatch Induced Stress Control Technology

Tuning the interlayer microstructure and residual stress of buffer-free direct bonding GaN/Si heterostructures

Epitaxial Growth of GaN-based Heterostructures of High Quality on Si Substrates Using a Large Lattice-Mismatch Induced Stress Control Technology

Electrical and Structural Properties of AlGaN/GaN Heterostructures Grown onto 8°-Off-Axis 4H-SiC Epilayers

Strain Release Enabled Bandgap Scaling in Ge Nanowire and Tunnel FET Application

Epitaxial Lift-Off of Flexible GaN-Based HEMT Arrays with Performances Optimization by the Piezotronic Effect

Strained GaN Quantum-Well FETs on Single Crystal Bulk AlN Substrates

Inaln/Gan Heterostructure Field-Effect Transistors on Fe-Doped Semi-Insulating Gan Substrates

Growth of GaN Quasi‐substrates by Hydride Vapor Phase Epitaxy

Integration of Highly Strained Sige in Source and Drain with Hk and Mg for 22 Nm Bulk Pmos Transistors

Strain-Induced Lateral Heterostructures in Patterned Semiconductor Nanomembranes for Micro- and Optoelectronics

Fabrication and Characterization of Strained Si Material Using SiGe Virtual Substrate for High Mobility Devices

Epitaxy of Single‐Crystalline GaN Film on CMOS‐Compatible Si(100) Substrate Buffered by Graphene