Abstract:The experimental and theoretical researches have been carried out to get the flow boiling heat transfer characteristics of carbon dioxide (CO2 or R744) as a refrigerant in horizontal minichannel. Based on infrared thermal imaging tests and experimental studies on heat transfer coefficients, the heat transfer coefficients and dryout characteristics of CO2 are analyzed qualitatively and quantitatively in following conditions: Heat flux: 2 similar to 35 kW m(-2), Mass flux: 50 similar to 1350 kgm(-2) s(-1), saturation temperature: -10 similar to 15 degrees C, mini-channel inner diameter: 1 mmand 2 mm. Primary conclusions can be drawn from the results of the experiments: The increase of heat flux enhances the nucleate boiling heat transfer of the refrigerant inside mini-channel, which leads to the remarkable increase of heat transfer coefficient. But it speeds up the process of dryout. It also has a certain influence on vapor qualities of dryout at both the starting and the ending stage. The effect of mass flux on heat transfer enhancement depends on the dominant heat transfer mode in the tube. With the increase of mass flow rate, the vapor quality at the start of dryout has a decreasing trend. But the heat transfer coefficient increases at the end of dryout process or even after dryout process; the heat transfer coefficient does not vary monotonically with the saturation temperature: when the saturation temperature is high and even close to CO2' s critical temperature, the heat transfer coefficient increases with the increase of saturation temperature; when the saturation temperature is low, the heat transfer coefficient increases with the decrease of saturation temperature. Besides, during the heat transfer process, the dryout vapor quality falls monotonically with the increase of saturation temperature. It is reasonable to conclude that dryout characteristics have significant influence on heat transfer coefficient. Fang correlation that predicts the heat transfer coefficient of CO2 is in good agreement with the experimental data, which has a mean absolute deviation of 15.7%, and predicts 71.98% of the entire database within similar to 20% and 86.84% of the entire database within similar to 30%. (C) 2017 Elsevier Ltd and IIR. All rights reserved.

Flow boiling heat transfer Coefficient used for the Design of the Evaporator of a Refrigeration Machine using CO2 as Working Fluid

A Research on the Dryout Characteristics of CO 2 'S Flow Boiling Heat Transfer Process in Mini-Channels

Study of Heat Transfer for Co2 Flow Boiling in Horizontal Small Diameter Tubes

Characteristics of Heat Transfer for CO2 Flow Boiling in Mini_channel

A new correlation for carbon dioxide boiling heat transfer coefficient outside evaporating tubes

Characteristics of Heat Transfer for CO2 Flow Boiling at Low Temperature in Mini-Channel

Development and Validation of Helical-Coil-in-fluted-tube Gas Cooler for CO2 Heat Pump Water Heaters

Influencing factors on flow boiling of carbon dioxide in enhanced tubes and comparison with correlations

EXPERIMENTAL STUDY ON EVAPORATING HEAT TRANSFER OF CO2 IN THIN TUBE

Experimental Research on Heat Transfer Performance of CO2 Tube Bundle Falling Film Evaporator

Investigation of Flow Boiling Heat Transfer Characteristics of CO2in Horizontal Mini-Tube

Evaluation of Heat Transfer Coefficient of Two-Phase Flow Boiling with R290 in Horizontal Mini Channel

Heat Transfer Performance Analysis on the CO2 Two-phase Thermosyphon Loop

Characteristics of Flow Boiling Heat Transfer of Sub-Critical CO2 in Mini-Channels with Micro-Fins

Theoretical Analysis on a Novel Two-Stage Compression Transcritical CO2 Dual-Evaporator Refrigeration Cycle with an Ejector

A General Correlation for Saturated Two-Phase Flow Boiling Heat Transfer Inside Horizontal and Vertical Tubes

Flow Boiling in Dimpled Plate Heat Exchangers with Different Geometric Parameters: Analysis of Asymmetric Channels

Numerical Analysis on the Evaporative Heat Transfer of Co2 at Different Inlet Reynolds Numbers

A Study of the Heat Transfer Coefficient of a Mini Channel Evaporator with R-134a as Refrigerant

Experiments and Heat Transfer Correlation Validations of Low-Parameter Region of sCO2 Flow in a Long Thin Vertical Loop

A Modified Correlation for Flow Boiling Heat Transfer in Plate Heat Exchangers