Abstract:Methane pyrolysis is a transitional technology for environmentally benign hydrogen production with zero greenhouse gas emissions, especially when concentrated solar energy is the heating source for supplying high-temperature process heat. This study is focused on solar methane pyrolysis as an attractive decarbonization process to produce both hydrogen gas and solid carbon with zero CO2 emissions. Direct normal irradiance (DNI) variations arising from inherent solar resource variability (clouds, fog, day-night cycle, etc.) generally hinder continuity and stability of the solar process. Therefore, a novel hybrid solar/electric reactor was designed at PROMES-CNRS laboratory to cope with DNI variations. Such a design features electric heating when the DNI is low and can potentially boost the thermochemical performance of the process when coupled solar/electric heating is applied thanks to an enlarged heated zone. Computational fluid dynamics (CFD) simulations through ANSYS Fluent were performed to investigate the performance of this reactor under different operating conditions. More particularly, the influence of various process parameters including temperature, gas residence time, methane dilution, and hybridization on the methane conversion was assessed. The model combined fluid flow hydrodynamics and heat and mass transfer coupled with gas-phase pyrolysis reactions. Increasing the heating temperature was found to boost methane conversion (91% at 1473 K against ~100% at 1573 K for a coupled solar-electric heating). The increase of inlet gas flow rate Q0 lowered methane conversion since it affected the gas space-time (91% at Q0 = 0.42 NL/min vs. 67% at Q0 = 0.84 NL/min). A coupled heating also resulted in significantly better performance than with only electric heating, because it broadened the hot zone (91% vs. 75% methane conversion for coupled heating and only electric heating, respectively). The model was further validated with experimental results of methane pyrolysis. This study demonstrates the potential of the hybrid reactor for solar-driven methane pyrolysis as a promising route toward clean hydrogen and carbon production and further highlights the role of key parameters to improve the process performance.

Improvement of Plasma Reactor Design for Methane Pyrolysis by Simulation

Kinetic Modeling and Experimental Validation of the Pyrolysis of Propane in Hydrogen Plasma

Numerical Simulation of the Entrained Flow Hydropyrolysis of Coal in Magnetically Rotating Plasma Reactor

Development and Process of Pyrolysis of Light Alkanes to Acetylene by Thermal Plasma

Numerical Simulation Study on Plasma Rapid Heater of Methane

Experimental Comparison of Methane Pyrolysis in Thermal Plasma

From simulation to reality: CFD-ML-driven structural optimization and experimental analysis of thermal plasma reactors

On design of plasma jet reactor for non-oxidative methane conversion

A Thermally Autonomous Methanol Steam Reforming Microreactor with Porous Copper Foam As Catalyst Support for Hydrogen Production

Numerical Study of Methane to Acetylene Process in Novel Thermal Plasma Array Reactor

Feasibility of a Plasma Furnace for Methane Pyrolysis: Hydrogen and Carbon Production

Methane Dry Reforming over Ni/Al2O3 Catalyst in Spark Plasma Reactor: Linking Computational Fluid Dynamics (CFD) with Reaction Kinetic Modelling

Optimization of Discharge Plasma Reactor for Dry Reforming of Methane using Response Surface Methodology

Optimization of Coal Pyrolysis in Thermal Plasma Reactor

CHALLENGES FOR THE DEVELOPMENT OF NUMERICAL MODELS FOR METHANE PYROLYSIS WITH LIQUID METAL REACTORS

Comparative analysis of methane conversion: pyrolysis, dry and steam thermal plasma reforming

CFD Simulation of a Hybrid Solar/Electric Reactor for Hydrogen and Carbon Production from Methane Cracking

Hydrogen Production from Methane Decomposition in Cold Plasma Reactor with Rotating Electrodes

Gas–solid reactor optimization based on EMMS-DPM simulation and machine learning

Hydrogen Production From Partial Oxidation Of Methane Using An Ac Rotating Gliding Arc Reactor

Process Development and Reactor Analysis of Coal Pyrolysis to Acetylene in Hydrogen Plasma Reactor