Abstract:β-phase gallium oxide (Ga2O3) is an emerging ultrawide bandgap (UWBG) semiconductor (EG ∼ 4.8 eV), which promises generational improvements in the performance and manufacturing cost over today's commercial wide bandgap power electronics based on GaN and SiC. However, overheating has been identified as a major bottleneck to the performance and commercialization of Ga2O3 device technologies. In this work, a novel Ga2O3/4H-SiC composite wafer with high heat transfer performance and an epi-ready surface finish has been developed using a fusion-bonding method. By taking advantage of low-temperature metalorganic vapor phase epitaxy, a Ga2O3 epitaxial layer was successfully grown on the composite wafer while maintaining the structural integrity of the composite wafer without causing interface damage. An atomically smooth homoepitaxial film with a room-temperature Hall mobility of ∼94 cm2/Vs and a volume charge of ∼3 × 1017 cm–3 was achieved at a growth temperature of 600 °C. Phonon transport across the Ga2O3/4H-SiC interface has been studied using frequency-domain thermoreflectance and a differential steady-state thermoreflectance approach. Scanning transmission electron microscopy analysis suggests that phonon transport across the Ga2O3/4H-SiC interface is dominated by the thickness of the SiNx bonding layer and an unintentionally formed SiOx interlayer. Extrinsic effects that impact the thermal conductivity of the 6.5 μm thick Ga2O3 layer were studied via time-domain thermoreflectance. Thermal simulation was performed to estimate the improvement of the thermal performance of a hypothetical single-finger Ga2O3 metal–semiconductor field-effect transistor fabricated on the composite substrate. This novel power transistor topology resulted in a ∼4.3× reduction in the junction-to-package device thermal resistance. Furthermore, an even more pronounced cooling effect is demonstrated when the composite wafer is implemented into the device design of practical multifinger devices. These innovations in device-level thermal management give promise to the full exploitation of the promising benefits of the UWBG material, which will lead to significant improvements in the power density and efficiency of power electronics over current state-of-the-art commercial devices.This article has not yet been cited by other publications.

Insulator-to-semiconductor conversion of solution-processed ultra-wide bandgap amorphous gallium oxide via hydrogen annealing

Modulation of Interfacial and Electrical Properties of Hfgdo/Gaas Gate Stacks by Ammonium Sulfide Passivation and Rapid Thermal Annealing

Modulation of Interfacial and Electrical Properties of ALD-derived HfAlO/Al2O3/Si Gate Stack by Annealing Temperature

Evolution of Interface Chemistry and Dielectric Properties of Hfo2/Ge Gate Stack Modulated by Gd Incorporation and Thermal Annealing

Hydrogen-included plasma-assisted reactive sputtering for conductivity control of ultra-wide bandgap amorphous gallium oxide

Chemical manipulation of hydrogen induced high p-type and n-type conductivity in Ga2O3

Facile synthesis of β-Ga2O3 based high-performance electronic devices via direct oxidation of solution-processed transition metal dichalcogenides

Solution-processed amorphous gallium oxide gate dielectric for low-voltage operation oxide thin film transistors

Progress of power field effect transistor based on ultra-wide bandgap Ga2O3 semiconductor material

Ga 2 O 3 -on-SiC Composite Wafer for Thermal Management of Ultrawide Bandgap Electronics

Ga2O3-on-SiC Composite Wafer for Thermal Management of Ultrawide Bandgap Electronics

Extended Scalability of HfON/SiON Gate Stack Down to 0.57 nm Equivalent Oxide Thickness with High Carrier Mobility by Post-Deposition Annealing

Interface-induced origin of Schottky-to-Ohmic-to-Schottky conversion in non-conventional contact to β -Ga2O3

Tunable Electronic, Transport, and Optical Properties of Fluorine and Hydrogen Passivated Two-Dimensional Ga2O3 by Uniaxial Strain

Computational Fermi level engineering and doping-type conversion of Ga2O3 via three-step synthesis process

Hydrogen-Doping-Enabled Boosting of the Carrier Mobility and Stability in Amorphous IGZTO Transistors

Development of gallium oxide power devices (Phys. Status Solidi A 1∕2014)

Ultra-Wide Band Gap Ga2O3-on-SiC MOSFETs

Effects of implementing dual-step nitrogen ambient for growth and post-deposition annealing of Ga2O3 films sputtered on silicon

Aqueous-solution-synthesized gallium oxide dielectrics for high-mobility thin-film transistors enhanced by phosphorus incorporation

Ga2O3 and Related Ultra-Wide Bandgap Power Semiconductor Oxides: New Energy Electronics Solutions for CO2 Emission Mitigation