Abstract:In the presence of a catalyst, the reforming of biomass tar to produce syngas, and its further use for chemical production, is a sustainable energy technology. However, to the best of our knowledge, the integration of tar reforming and downstream technology is still limited. In this work, an economical Ni/biochar catalyst was prepared and successfully applied for steam reforming of toluene (as a tar model compound) and syngas methanation. Under experimental conditions, the Ni/wheat straw (Ni/WS) char catalyst is active for syngas production and further for methane production in a wide temperature range. The physicochemical properties of the Ni/WS char catalyst were carefully characterized, and then the activity, stability, and deactivation of Ni/WS char in toluene reforming and methanation were elaborated. Ni/WS char possessed a smaller Ni crystallite size, and its lower activation energy resulted in higher toluene conversion (90.2%) and gas yield (261.4 mmol/gtoluene) compared with the commercial Ni/Al2O3 catalyst during toluene reforming. Furthermore, the produced syngas with an optimized H2/CO ratio of 3.01 was proved to be suitable for methane production over Ni/WS char, which therefore showed a high CO conversion (80.3%).The Supporting Information is available free of charge at https://pubs.acs.org/doi/10.1021/acssuschemeng.1c03497.Proximate and ultimate analyses of wheat straw; activity comparison and reaction conditions of different Ni-based catalysts in toluene reforming; activity comparison and reaction conditions of different Ni-based catalysts in CO methanation; weight changes of spent Ni/WSC-R and Ni/Al2O3-R at different temperatures and different S/C ratios; weight changes of spent Ni/WSC-R and Ni/Al2O3-R after 15 h TOS of SRT; TG curves of spent Ni/WSC-R and spent Ni/Al2O3-R (after 15 h TOS of SRT) and spent Ni/WSC-M and Ni/Al2O3-M (after 50 h TOS of methanation); weight changes of spent Ni/WSC-M and Ni/Al2O3-M at different temperatures and after 50 h TOS of methanation (PDF)This article has not yet been cited by other publications.

Syngas production by catalytic pyrolysis of rice straw over modified Ni-based catalyst

Effective Catalytic of Rice Straw Pyrolysis over Ni/CaZnAl Catalyst for Producing Hydrogen-Rich Syngas

Investigating the Catalytic Influence of Boron on Ni-Co/Ca Catalysts for Improved Syngas Generation from Rice Straw Pyrolysis

Hydrogen-rich syngas production via catalytic gasification of sewage sludge and wheat straw using corn stalk char-supported catalysts

Investigating the effect of nano-nickel-based catalyst Ni-Me/HZSM-5 on in situ catalytic pyrolysis of distillers dried grains with solubles

Preparation of hydrogen-rich gas by catalytic pyrolysis of straw-plastic mixture with nickel-based honeycomb cinder

Partial Oxidation Of Methane To Syngas Over Ni-Based Catalysts

Catalytic Pyrolysis of Rice Straw for High Yield of Aromatics over Modified ZSM-5 Catalysts and Its Kinetics

Gasification and catalytic reforming of corn straw in closed-loop reactor

Preparation of Syngas Via Catalytic Gasification of Biomass with a Nickel-based Catalyst

Syngas Characteristics From Catalytic Gasification of Polystyrene and Pinewood in CO2 Atmosphere

Pyrolysis waste char supported metallic catalyst for syngas production during catalytic reforming of benzene

Catalysis/sorption enhanced pyrolysis-gasification of biomass for H 2 -rich gas production: Effects of various nickel-based catalysts addition and the combination with calcined dolomite

Experimental study on catalytic pyrolysis of biomass over a Ni/Ca-promoted Fe catalyst

Direct Conversion of Syngas Produced from Steam Reforming of Toluene into Methane over a Ni/Biochar Catalyst

Performance of Alkali and Ni-modified ZSM-5 During Catalytic Pyrolysis of Extracted Hemicellulose from Rice Straw for the Production of Aromatic Hydrocarbons

Catalytic Methanation of Syngas over Ni-based Catalysts with Different Supports

Preparation of Sustainable Ni/SiO2 Catalysts from Rice Husk by Different Methods for CO2 Methanation

Catalytic conversion of methane and CO2 to synthesis gas over a La2O3-modified SiO2 supported Ni catalyst in fluidized-bed reactor

Co‐pyrolysis of cypress sawdust and green algae over Ni/ZrO2 catalyst: Syngas yield and carbon emission

Nanocatalysts Anchored on Nanofiber Support for High Syngas Production Via Methane Partial Oxidation