Abstract:Top-gate self-aligned structured oxide thin-film transistors (TFTs) are suitable for the backplanes of high-end displays because of their low parasitic capacitances. The gate insulator (GI) deposition process should be carefully designed to manufacture a highly stable, high-mobility oxide TFT, particularly for a top-gate structure. In this study, a nanometer-thick Al2O3 layer via plasma-enhanced atomic layer deposition (PE-ALD) is deposited on the top-gate bottom-contact structured oxide TFT as the interface tailoring layer, which can also act as the hydrogen barrier to modulate carrier generation from hydrogen incorporation into the active layer of the TFT during the following process such as postannealing. Al-doped InSnZnO (Al/ITZO) with an Al/In/Sn/Zn atomic ratio composition of 1.7:24.3:40:34 was used for high mobility oxide semiconductors, and an Al2O3/Si3N4 bilayer was used for the GI. The degradation issue due to the excellent barrier characteristics of Al2O3 and Si3N4 can be minimized. An oxide TFT fabricated without the interface tailoring layer exhibits conductor-like characteristics owing to the excessive carrier generation by hydrogen incorporation. However, TFTs with additional interface layers exhibit reasonable characteristics and distinct trends in electrical characteristics depending on the thicknesses of the interface layers. The optimized devices exhibit an average turn-on voltage (Von) of -0.31 V with 33.63 cm2/(V s) of high mobility and 0.09 V/dec of subthreshold swing value. The interfaces between the active layer and hydrogen barriers were investigated using a high-resolution transmission electron microscope, contact angle measurement, and secondary ion mass spectroscopy to reveal the origin of the trends in properties between the devices. The top-gate device with a hydrogen barrier using the four-cycle deposition exhibits optimum electrical characteristics of both high mobility and good stability with only a 0.04 V shift of Von under positive-bias temperature stress (PBTS). We realize a high-end, self-aligned TFT with high mobility [34.7 cm2/(V s)] and negligible Von shift of -0.06 V under PBTS by applying a subnanometer hydrogen barrier.

Impact of STI Gap-Fill Process Deposited by HDP-CVD in Flash Memory

Goi Improvement in 65nm Sacrificial Oxide Free Process Integration

The Study of Shallow Trench Isolation Gap-Fill for 28nm Node and Beyond

Visualization on Charge Distribution Behavior in Thickness-Scalable HfO2 Trapping Layer by In-Situ Electron Holography and Kelvin Probe Force Microscopy Technology

Approach to Low Contact Resistance Formation on Buried Interface in Oxide Thin-Film Transistors: Utilization of Palladium-Mediated Hydrogen Pathway

Scalability And Reliability Characteristics Of Cvd Hfo2 Gate Dielectrics With Hfn Electrodes For Advanced Cmos Applications

Dynamic Observation of Oxygen Vacancies in Hafnia Layer by in Situ Transmission Electron Microscopy

Comparative studies on vertical-channel charge-trap memory thin-film transistors using In-Ga-Zn-O active channels deposited by sputtering and atomic layer depositions

Effect of Fluorine on Formation of Hillock Defect in Copper Metallization and Methods to Remove Them

Defect Engineering of Hafnia-Based Ferroelectric Materials for High-Endurance Memory Applications

Investigation of STI edge effect on programming disturb in localized charge trapping SONOS flash memory cells.

Evaluation and Solutions for P/E Window Instability Induced by Electron Trapping in High-Kappa Intergate Dielectrics of Flash Memory Cells

Engineering a Subnanometer Interface Tailoring Layer for Precise Hydrogen Incorporation and Defect Passivation for High-End Oxide Thin-Film Transistors

A novel solution to improve static and dynamic retention characteristics by enhancing hydrogen passivation with in situ LD-TEOS/TEOS dual layer

Interstitial Oxygen-Related Defects And Current Leakage In Trench Metal-Oxide-Semiconductor Field-Effect Transistor On Epi/As++ Structure

Effect of Bias Frequency on Bottom-Up SiO 2 Gap-Filling Using Plasma-Enhanced Atomic Layer Deposition

Optimization of Interlevel Dielectrics for Embedded Nonvolatile Deep Submicrometer Technologies

Beneficial Hydrogen Doping in Single Spinel Phase Crystallized IZTO Thin-Film Transistors

The Influence of Deep-Level Defects With Various Depths in SiO<sub>2</sub> on Ionizing Damage

Investigation of Impact of Shallow Trench Isolation on SONOS Type Memory Cells

Interface engineering of 9X stacked 3D NAND flash memory using hydrogen post-treatment annealing