Abstract:Deactivation of a sulfided CoMo/MgAl2O4 catalyst during fluid bed catalytic hydropyrolysis of biomass (beech wood) was studied. The stability of the catalyst was investigated by converting approximately 4.4 kg of biomass and collecting the liquid and solid products for every 1 kg fed, using the same catalyst load. The total time on stream was 16.2 h. A secondary hydrotreating reactor with a sulfided NiMo/Al2O3 catalyst was used after the fluid bed to further deoxygenate the vapors. The condensed organics and C4+ gases yield for each 1 kg fed was 22.2 ± 1 wt %, which was variations within the experimental uncertainty. The CO and CO2 yield during the experiment increased from 14.9 to 18.2 wt % daf, while the aqueous phase yield decreased from 38.0 to 35.1 wt % daf. The change in CO, CO2, and aqueous phase yields was ascribed to a decrease in hydrodeoxygenation activity of the used catalysts. The concentration of oxygen in the condensed organic phase increased from 40 to 2832 ppm, indicating that deactivation of the catalyst in both the fluid bed and the HDO reactor occurred. Our previous study (Stummann etal. Energy Fuels 2019, 33, 1302–1313.) has shown that potassium, a known catalyst poison, is transferred from the beech wood to the catalyst, and the effect of doping the catalyst with 1.9 wt % potassium was therefore also investigated. The results were compared to a similar experiment with a fresh catalyst. Both experiments were performed without the downstream hydrotreating reactor to show the effect on the chemistry in the fluid bed reactor only. This showed that potassium decreased the catalyst's cracking, hydrogenation, and hydrodeoxygenation activity. Doping the catalyst with potassium also increased the char and coke yield from 13.3 to 14.6 wt % daf, indicating that potassium can act as a catalyst for polymerization of the pyrolysis vapors. Overall, the results not only show promise for using CoMo based catalysts for catalytic hydropyrolysis but also indicate that attention should be paid to catalyst deactivation.

Raney-Nickel Catalyst Deactivation in Supercritical Water Gasification of Ethanol Fermentation Stillage and its Mitigation

Deactivation and Regeneration of Raney-Ni Catalyst During Multiphase Dehydrogenation of Cyclohexane

Engineering Functional Hydrochar Based Catalyst with Corn Stover and Model Components for Efficient Glucose Isomerization

Molecular Dynamics Simulations Guide the Gasification Process of Carbon-Supported Nickel Catalysts in Biomass Supercritical Water

Efficient and Stable Supercritical-Water-synthesized Ni-based Catalysts for Supercritical Water Gasification

Catalytic Properties and Recycling of NiFe2O4 Catalyst for Hydrogen Production by Supercritical Water Gasification of Eucalyptus Wood Chips

Investigation of the Performance and Deactivation Behavior of Raney-Ni Catalyst in Continuous Dehydrogenation of Cyclohexane under Multiphase Reaction Conditions

Spontaneous regeneration of active sites against catalyst deactivation

Catalyst Deactivation and Regeneration Processes in Biogas Tri-Reforming Process. The Effect of Hydrogen Sulfide Addition

Catalysis in Supercritical Water Gasification of Biomass: Status and Prospects

Supercritical Water Gasification as Treatment for High Lipid Content Biomass in the Presence of Nickel Catalyst

Catalyst Deactivation of Rh-Coated Foam Monolith for Catalytic Partial Oxidation of Methane

Catalytic Biomass Transformation to Hydrocarbons under Supercritical Conditions over Nickel Supported on Schungite

Sustainable carbon-based nickel catalysts for the steam reforming of model compounds of pyrolysis liquids

Catalyst Deactivation and Its Mitigation during Catalytic Conversions of Biomass

Effective regeneration of deactivated Raney-Ni catalyst during multiphase hydrogenation of vegetable oil

Water-induced deactivation of cobalt-based Fischer–Tropsch catalysts

Deactivation of a CoMo Catalyst during Catalytic Hydropyrolysis of Biomass. Part 1. Product Distribution and Composition

Experimental Study on Sulfur Deactivation and Regeneration of Ni-Based Catalyst in Dry Reforming of Biogas

Nickel and Iron‐Doped Biocarbon Catalysts for Reverse Water‐Gas Shift Reaction

Nickel nanocatalysts prepared via continuous supercritical hydrothermal synthesis for supercritical water gasification