Abstract:Highly efficient hydrogen production from biomass can be realized by using catalysts in the reaction process under more mild hydrothermal conditions. Among various catalysts, Ni based catalysts are considered as the most promising catalyst for hydrogen production due to its low cost and good catalytic activity. In order to solve the problem of catalyst deactivation caused by carbon deposion at the acid site of Ni/Al2O3,the additives were studied to modify the Ni based catalysts loaded on Al2O3 in our research group. Cu, Co, Ce and Mg were chosed as additive and bimetal Ni-M or complex oxide catalysts were prepared by co-impregnation, impregnation by step, and co-precipitation, etc. The results show that the introduction of metal Ce can effectively improve the catalytic activity of hydrogen production, and the resistance of carbon deposition can also be improved, indicating that metal Ce is a suitable additive. Mg additive can restrain the formation of crystalline carbon on the surface of Ni-Al catalyst. Much lower heat-treating temperature or impregnation by step in preparation can obtain more effective active sites for Ni-Mg-Al catalyst. Moreover, Mg additive can improve the catalytic activity and hydrothermal stability of Ni-Al catalyst. As to the Ni catalyst loaded on rutile TiO2 prepared by sol-gel process, Ni crystals with much higher dispersity can be achieved by lowering the heat-treating temperature, which provide more active sites and promote the C-C bond breaking of biomass under hydrothermal conditions as well as water gas shift reaction and methanation reaction, thus improving the conversion efficiency of biomass. The thermodynamic analysis was performed with Aspen Plus V7.3.2. The thermodynamic models was built using the P-R equation of state and the MHV2 mixing rule to predict the gas yields in the hydrothermal gasification process. Hydrothermal gasification of biomass and its model compounds was theoretically analyzed. The equilibrium state of hydrothermal gasification reaction was obtained by calculating the gas production under certain temperature and pressure, which points out the direction and limitation of hydrothermal gasification reaction.

Supercritical Water Gasification as Treatment for High Lipid Content Biomass in the Presence of Nickel Catalyst

Effect of Nickel Nanocatalyst Loading on Supercritical Water Gasification of Coconut Shell

Hydrogen Production by Biomass Gasification in Supercritical Water over Ni/γAl2O3 and Ni/CeO2-γAl2O3 Catalysts

Supercritical Water Synthesis of Nano-Particle Catalyst on TiO2 and Its Application in Supercritical Water Gasification of Biomass

Catalytic Supercritical Water Gasification of Glucose with In-Situ Generated Nickel Nanoparticles for Hydrogen Production

Hydrogen production by biomass gasification in supercritical water over Ni/ gamma Al sub (2 O) sub (3) and Ni/CeO sub (2 gamma Al) sub (2) O sub (3 catalysts)

Catalytic Biomass Transformation to Hydrocarbons under Supercritical Conditions over Nickel Supported on Schungite

Catalytic Supercritical Water Gasification of Canola Straw with Promoted and Supported Nickel-Based Catalysts

Hydrogen Production by Biomass Gasification in Supercritical or Subcritical Water with Raney-Ni and Other Catalysts

Hydrogen Production by Supercritical Water Gasification of Biomass with Homogeneous and Heterogeneous Catalyst

Nickel nanocatalysts prepared via continuous supercritical hydrothermal synthesis for supercritical water gasification

Hydrogen-rich gas production through supercritical water gasification of chicken manure over activated carbon/ceria-based nickel catalysts

Catalytic Performances of Ni-based Catalysts on Supercritical Water Gasification of Phenol Solution and Coal-Gasification Wastewater

Hydrogen Production by Hydrothermal Gasification of Biomass：Catalysts and Thermodynamic Analysis

Stability and Activity of a Co-Precipitated Mg Promoted Ni/Al2O3 Catalyst for Supercritical Water Gasification of Biomass

Supercritical water Co-gasification of biomass and plastic wastes for hydrogen-rich gas production using Ni-Cu/AC-CaO catalyst

Hydrogen Production from Supercritical Water Gasification of Lignin Catalyzed by Ni Supported on Various Zeolites

Co-precipitated Ni–Mg–Al Catalysts for Hydrogen Production by Supercritical Water Gasification of Glucose

Evaluation of Stability and Catalytic Activity of Ni Catalysts for Hydrogen Production by Biomass Gasification in Supercritical Water

Hydrogen production by biomass gasification in supercritical water with bimetallic Ni-M/γAl2O3 catalysts (M = Cu, Co and Sn)

Enhanced Hydrogen Production from Biomass Gasification by In-Situ CO2 Capture with Ni/Ca-based Catalysts