Abstract:Highly efficient hydrogen production from biomass can be realized by using catalysts in the reaction process under more mild hydrothermal conditions. Among various catalysts, Ni based catalysts are considered as the most promising catalyst for hydrogen production due to its low cost and good catalytic activity. In order to solve the problem of catalyst deactivation caused by carbon deposion at the acid site of Ni/Al2O3,the additives were studied to modify the Ni based catalysts loaded on Al2O3 in our research group. Cu, Co, Ce and Mg were chosed as additive and bimetal Ni-M or complex oxide catalysts were prepared by co-impregnation, impregnation by step, and co-precipitation, etc. The results show that the introduction of metal Ce can effectively improve the catalytic activity of hydrogen production, and the resistance of carbon deposition can also be improved, indicating that metal Ce is a suitable additive. Mg additive can restrain the formation of crystalline carbon on the surface of Ni-Al catalyst. Much lower heat-treating temperature or impregnation by step in preparation can obtain more effective active sites for Ni-Mg-Al catalyst. Moreover, Mg additive can improve the catalytic activity and hydrothermal stability of Ni-Al catalyst. As to the Ni catalyst loaded on rutile TiO2 prepared by sol-gel process, Ni crystals with much higher dispersity can be achieved by lowering the heat-treating temperature, which provide more active sites and promote the C-C bond breaking of biomass under hydrothermal conditions as well as water gas shift reaction and methanation reaction, thus improving the conversion efficiency of biomass. The thermodynamic analysis was performed with Aspen Plus V7.3.2. The thermodynamic models was built using the P-R equation of state and the MHV2 mixing rule to predict the gas yields in the hydrothermal gasification process. Hydrothermal gasification of biomass and its model compounds was theoretically analyzed. The equilibrium state of hydrothermal gasification reaction was obtained by calculating the gas production under certain temperature and pressure, which points out the direction and limitation of hydrothermal gasification reaction.

Hydrogen-rich gas production through supercritical water gasification of chicken manure over activated carbon/ceria-based nickel catalysts

Hydrogen Production from Supercritical Water Gasification of Chicken Manure

Gasification of Pig Manure for Hydrogen Production in Supercritical Water: Reaction Variables, Product, and Mechanism Analysis

Optimize hydrogen production from chicken manure gasification in supercritical water by experimental and kinetics study

Development of Nickel-Based Bimetallic Catalysts for Production of Hydrogen-Rich Syngas Via Supercritical Water Gasification of Liquid Residue from Hydrothermal Pretreatment of Food Waste

Hydrogen Production by Biomass Gasification in Supercritical Water over Ni/γAl2O3 and Ni/CeO2-γAl2O3 Catalysts

Hydrogen Production By Sewage Sludge Gasification In Supercritical Water With High Heating Rate Batch Reactor

Characteristic of Food Waste Gasification in Supercritical Water for Hydrogen Production

Carbonization and Gasification of Cow‐Dung and Fe3O4 Nanoparticles at Different Operating Conditions for Hydrogen Production

Hydrogen Production by Supercritical Water Gasification of Biomass with Homogeneous and Heterogeneous Catalyst

Hydrogen-rich syngas production via catalytic gasification of sewage sludge and wheat straw using corn stalk char-supported catalysts

Evaluation of Catalytic Subcritical Water Gasification of Food Waste for Hydrogen Production: Effect of Process Conditions and Different Types of Catalyst Loading

Catalytic Supercritical Water Gasiﬁcation of Oily Sludge with the FeOOH/AC for Hydrogen Production

Clean conversion of pig manure via supercritical water gasification: Hydrogen-enriched syngas generation, mechanisms analysis, and environmental impacts

Catalytic Gasification of Sewage Sludge in Near and Supercritical Water with Different Catalysts

Study on Hydrogen Production by Supercritical Water Gasification of Unsymmetrical Dimethylhydrazine under Multi-Parameters

HYDROGEN PRODUCTION FROM CHICKEN MANURE BY SUPERCRITICAL WATER GASIFICATION IN A FLUIDIZED BED REACTOR

Hydrogen Production by Hydrothermal Gasification of Biomass：Catalysts and Thermodynamic Analysis

Hydrogen production by biomass gasification in supercritical water over Ni/ gamma Al sub (2 O) sub (3) and Ni/CeO sub (2 gamma Al) sub (2) O sub (3 catalysts)

Hydrogen Production from Supercritical Water Gasification of Lignin Catalyzed by Ni Supported on Various Zeolites

Supercritical Water Gasification as Treatment for High Lipid Content Biomass in the Presence of Nickel Catalyst