Abstract:ZrO2 is a versatile material with diverse applications, including structural ceramics, sensors, and catalysts. The properties of ZrO2 are largely determined by its crystal structure, which is temperature‐ and atmosphere dependent. Thus, this work focuses on a quantitative analysis of the temperature‐ and gas atmosphere‐dependent phase transformation of tetragonal t‐ZrO2 into monoclinic m‐ZrO2 during heating–cooling cycles from room temperature to 1273 K. Synchrotron‐based in situ X‐ray diffraction (XRD) studies in gas atmospheres of different reduction strengths, namely, 5 vol% H2/Ar, He, CO2, and air, revealed a stabilizing effect of inert and reductive environments, directly yielding different temperature onsets in the phase transformation during cooling (i.e., 435, 510, 710, and 793 K for 5 vol% H2/Ar, He, CO2, and air, respectively). Rietveld refinement shows a direct influence of the atmosphere on grain size, unit cell, and weight fraction of both polymorphs in the product composite matrix. The tetragonal‐to‐monoclinic (t–m) phase transformation is suppressed in the sample heated only up to ∼850 K, independent of the gas atmosphere. The results of ex situ XRD, transmission electron microscopic, electron paramagnetic resonance, and oxygen titration experiments confirmed that the phase transformation is accompanied by a change in the crystallite/particle size and the amount of lattice defects (i.e., oxygen vacancy). Due to the different onset temperatures, a complex interplay between kinetic limitations of phase transformation and grain sintering yields different pathways of the phase transformation and, eventually, very different final crystallite sizes of both t‐ZrO2 and m‐ZrO2.

Phase Transformation Temperatures and Solute Redistribution in a Quaternary Zirconium Alloy

Ab Initio Calculations of the Thermodynamics and Phase Diagram of Zirconium

Deformation behavior and Microstructural evolution of Zr‐Sn‐Nb‐Fe alloy over a wide temperature range based on the law of mixture

Amorphous-to-Cu51Zr14phase Transformation in Cu60Ti20Zr20alloy

Phase transformations in Ti-Nb-Ta and Ti-Nb-Ta-Zr alloys

Decomposition of Amorphous Zr41ti14cu12.5ni10be22.5 Alloy: As Investigated by Small Angle Neutron Scattering

A quantitative microscopic view on the gas‐phase‐dependent phase transformation from tetragonal to monoclinic ZrO2

New Insights into Solidification and Phase Equilibria in the Al-Al3Zr System: Theoretical and Experimental Investigations

Microstructure and Phase Transformation of Ni46Mn33Ga17Cu4−xZrx Alloys

The Influence of Phase Formation on Irradiation Tolerance in a Nanocrystalline TiZrNbHfTa Refractory High‐Entropy Alloy

In Situ Synchrotron Radiation X-ray Diffraction Study on Phase and Oxide Growth during a High Temperature Cycle of a NiTi-20 at.% Zr High Temperature Shape Memory Alloy

Crystalline phases found in rapidly quenched Ni-Nb-Zr alloys

Investigation of Intermediate Phases and Phase Transition Temperature of Α/β in the Zr-Sn-Nb-Fe Alloy

Atomic force microscopy study of the tetragonal to monoclinic transformation behaviour of silica doped yttria-stabilized zirconia

Phase Stability and Microstructural Evolution in a Ductile Refractory High Entropy Alloy Al 10 Nb 15 Ta 5 Ti 30 Zr 40

Regularities of Changes in the Structure of Different Phases of Deformed Zirconium Alloys as a Result of Raising the Annealing Temperature According to Texture Analysis Data

Phase Transformations of HfNbTaTiZr High-Entropy Alloy at Intermediate Temperatures

Phase Transformation And Microstructure Of Nbru High Temperature Shape Memory Alloy

In Situ Analysis of the Phase Transformation Kinetics in the β-Water-Quenched Ti-5Al-5Mo-5V-3Cr-1Zr Alloy during Ageing after Fast Heating

Deformation mechanisms of a novel multiphase Zr–30Ti–7Nb–4Sn alloy consisting of β, α′ and α′′ phases

In situ TEM investigation on the microstructure and phase evolution of hydrogenated Zr-4 alloy