Abstract:This study investigates the structural, morphological, optical, and electrical characteristics of Al 3+ and Sn 4+ doped ZnO nano-crystalline thin films fabricated using a sol–gel spin coating technique. The thin-films, with a uniform thickness of 200 nm (2% fabrication tolerance), were analyzed using scanning electron microscopy (SEM) and x-ray diffractometry (XRD) to evaluate surface profilometry, uniformity, and material compositions. The structural analysis revealed gradual improved crystalline properties up to 6 at.% Al doping and 4 at.% Sn doping, beyond which crystallinity deteriorated. Optical parameters, including optical conductivity, bandgaps, absorption index, and dielectric indices, were determined using an ultraviolet–visible (UV–Vis) spectrophotometer. The absorption indices (higher range in 0.0043–0.0046 mm for 2 at.% AZO) exhibited a non-linear relationship with bandgap energies in both types of films. The films demonstrated high mean transmittance (96%) and small grain size (~ 20 nm), indicating their suitability for various optoelectronic applications. The films also exhibited low carrier concentration rates, with specific concentrations showing optimal mobility and resistivity values. The highest and lowest FoM values were identified as 850 (10 –6 Ω −1 ) for 6 at.% Sn and 1.06 (10 –6 Ω −1 ) respectively. The study provides a rare comparison between AZO and SZO thin films, providing valuable insights into the enhanced properties of Al 3+ and Sn 4+ doped ZnO thin films, emphasizing their potential for diverse technological applications (e.g. optoelectronic devices and organic solar cells) used as conductive oxides and optically transparent electrodes.

Experimental and ab-initio investigation of the microstructure and optoelectronic properties of FCM–CVD-prepared Al-doped ZnO thin films

Preparation and Characterization of Mg-doped ZnO Thin Films by Sol–gel Method

Surface Topography and Optical Properties of Al-doped ZnO Thin Films by Sol-gel Process

Microstructure and Electrical Properties of Al-doped ZnO Thin Films

Microstructure, surface morphology and optical properties of Na x Cu y Zn 1− x − y O thin films

Microstructue and Optical Properties of Mg-doped ZnO Thin Films Prepared by Sol-gel Method

Effect of Al-doping on morphology, structure, and optical band gap of ZnO thin films synthesized by sol–gel spin-coating technique

Semiconducting properties of Al doped ZnO thin films

Investigation of dilute aluminum doped zinc oxide thin films: structural and morphological properties for varies applicationss

CMOS Compatible Al‐Doped ZnO Sol–Gel Thin‐Film Properties

Microstructure and optical properties of ZnAlO films prepared by Magnetron sputtering

Absorption edge shift and broadening in nanostructured Al doped ZnO thin films

Investigation of the Structural, Optical and Electrical Properties of Zinc Oxide Co-Doped with Fluorine and Cobalt

First-principle calculation of the electronic structure and optical properties of ZnO and Al:ZnO

Conductive and optically transparent sol–gel spin coated Al3+ and Sn4+ doped ZnO nano-crystalline thin-films

Optical and structural properties of Al-ZnO nanocomposites

Effect of film thickness on structural and optical properties of sol-gel spin coated aluminum doped zinc oxide (Al:ZnO) thin films

Effect of Al-doping on Crystallinity and Microstructure of ZnO:Al Thin Films

Influence of Al Doping on the Structural, Optical, and Electrical Characteristics of ZnMn2O4

Study on Microstructure and Electrical Properties of ZnO:Al Thin Films Prepared by Sol-gel Method

Optical and structural properties of Al-doped ZnO thin films by sol gel process