Abstract:The experimental and theoretical researches have been carried out to get the flow boiling heat transfer characteristics of carbon dioxide (CO2 or R744) as a refrigerant in horizontal minichannel. Based on infrared thermal imaging tests and experimental studies on heat transfer coefficients, the heat transfer coefficients and dryout characteristics of CO2 are analyzed qualitatively and quantitatively in following conditions: Heat flux: 2 similar to 35 kW m(-2), Mass flux: 50 similar to 1350 kgm(-2) s(-1), saturation temperature: -10 similar to 15 degrees C, mini-channel inner diameter: 1 mmand 2 mm. Primary conclusions can be drawn from the results of the experiments: The increase of heat flux enhances the nucleate boiling heat transfer of the refrigerant inside mini-channel, which leads to the remarkable increase of heat transfer coefficient. But it speeds up the process of dryout. It also has a certain influence on vapor qualities of dryout at both the starting and the ending stage. The effect of mass flux on heat transfer enhancement depends on the dominant heat transfer mode in the tube. With the increase of mass flow rate, the vapor quality at the start of dryout has a decreasing trend. But the heat transfer coefficient increases at the end of dryout process or even after dryout process; the heat transfer coefficient does not vary monotonically with the saturation temperature: when the saturation temperature is high and even close to CO2' s critical temperature, the heat transfer coefficient increases with the increase of saturation temperature; when the saturation temperature is low, the heat transfer coefficient increases with the decrease of saturation temperature. Besides, during the heat transfer process, the dryout vapor quality falls monotonically with the increase of saturation temperature. It is reasonable to conclude that dryout characteristics have significant influence on heat transfer coefficient. Fang correlation that predicts the heat transfer coefficient of CO2 is in good agreement with the experimental data, which has a mean absolute deviation of 15.7%, and predicts 71.98% of the entire database within similar to 20% and 86.84% of the entire database within similar to 30%. (C) 2017 Elsevier Ltd and IIR. All rights reserved.

Experimental investigation of dry ice cyclone separator for ultra‐low temperature energy storage using carbon dioxide

Visualization and Measurement of Swirling Flow of Dry Ice Particles in Cyclone Separator-Sublimator

Experimental Research on Low Supercooling of Ice Storage and Analysis of Its Energy Saving

1846 Study on Characteristic of Novel CO_2 Heat Pump with Cryogenic Temperature

Theoretical Investigation on the Performance of a Modified Refrigeration Cycle Using Binary Zeotropic Hydrocarbon Mixture R170/R290

Basic study on new cryogenic refrigeration using CO2 solid–gas two phase flow

Experimental Investigation on Heat Transfer of Co(2) Solid-Gas Two Phase Flow with Dry Ice Sublimation

Theoretical Analysis on a Novel Two-Stage Compression Transcritical CO2 Dual-Evaporator Refrigeration Cycle with an Ejector

Study on the CO[sub 2] Solid-Gas Two Phase Flow with Particle Sublimation and Its Basic Applications

A Novel CO2 Refrigeration System Achieved by CO2 Solid–gas Two-Phase Fluid and Its Basic Study on System Performance

A novel low-temperature absorption–compression cascade refrigeration system

Experimental Study on a Floating Scroll-Type Compressor Driving a Precooled JT Cryocooler

A Research on the Dryout Characteristics of CO 2 'S Flow Boiling Heat Transfer Process in Mini-Channels

Thermodynamic Analysis and Comparison Study of Two Novel Combined Cooling and Power Systems with Separators Using CO2-based Mixture for Low Grade Heat Source Recovery

Dynamics of Dry-ice Formation under Non-equilibrium Process and Operations in Low-pressure CO2 Shipping

Experimental and numerical analysis of the convective flow induced over a dry-ice bank with Particle Image Velocimetry

Parametric Study of a Novel Cryogenic-Membrane Hybrid System for Efficient CO2 Separation

EXPERIMENTAL STUDY ON EVAPORATING HEAT TRANSFER OF CO2 IN THIN TUBE

Experimental and Numerical Study of the Ice Storage Process and Material Properties of Ice Storage Coils

An Overview of a Two-stage Vapour Compression Cascade Refrigeration System for Low-temperature Applications

Experimental Study of Carbon Dioxide Desublimation and Sublimation Process on Low Temperature Surface