Abstract:NDIR CO2 gas sensors using a 10-cm-long gas channel and CMOS-compatible 12% doped ScAlN pyroelectric detector have previously demonstrated detection limits down to 25 ppm and fast response time of ∼2 s. Here, we increase the doping concentration of Sc to 20% in our ScAlN-based pyroelectric detector and miniaturize the gas channel by ∼65× volume with length reduction from 10 to 4 cm and diameter reduction from 5 to 1 mm. The CMOS-compatible 20% ScAlN-based pyroelectric detectors are fabricated over 8-in. wafers, allowing cost reduction leveraging on semiconductor manufacturing. Cross-sectional TEM images show the presence of abnormally oriented grains in the 20% ScAlN sensing layer in the pyroelectric detector stack. Optically, the absorption spectrum of the pyroelectric detector stack across the mid-infrared wavelength region shows ∼50% absorption at the CO2 absorption wavelength of 4.26 μm. The pyroelectric coefficient of these 20% ScAlN with abnormally oriented grains shows, in general, a higher value compared to that for 12% ScAlN. While keeping the temperature variation constant at 2 °C, we note that the pyroelectric coefficient seems to increase with background temperature. CO2 gas responses are measured for 20% ScAlN-based pyroelectric detectors in both 10-cm-long and 4-cm-long gas channels, respectively. The results show that for the miniaturized CO2 gas sensor, we are able to measure the gas response from 5000 ppm down to 100 ppm of CO2 gas concentration with CO2 gas response time of ∼5 s, sufficient for practical applications as the average outdoor CO2 level is ∼400 ppm. The selectivity of this miniaturized CO2 gas sensor is also tested by mixing CO2 with nitrogen and 49% sulfur hexafluoride, respectively. The results show high selectivity to CO2 with nitrogen and 49% sulfur hexafluoride each causing a minimum ∼0.39% and ∼0.36% signal voltage change, respectively. These results bring promise to compact and miniature low cost CO2 gas sensors based on pyroelectric detectors, which could possibly be integrated with consumer electronics for real-time air quality monitoring.

Carbon Dioxide Sensor Module Based on NDIR Technology

Non-modulating NDIR Sensor with Improved Signal Processing

Development of a Compact NDIR CO2 Gas Sensor for a Portable Gas Analyzer

A temperature-compensated CO2 detection system based on non-dispersive infrared spectral technology

A Novel Solid State Non-Dispersive Infrared CO2 Gas Sensor Compatible with Wireless and Portable Deployment

Development of High-Precision NO2 Gas Sensor Based on Non-Dispersive Infrared Technology

[Study on CO2 measurement using tunable multi-mode diode laser absorption spectroscopy]

Designing an optical gas chamber with stepped structure for non-dispersive infrared methane gas sensor

Novel NDIR CO2 sensor using a mid-IR hollow fiber as a gas cell

Multi-Gas Detection System Based on Non-Dispersive Infrared (NDIR) Spectral Technology

[Open-path online monitoring of ambient atmospheric CO2 based on laser absorption spectrum]

CH4, C2H6, and CO2 Multi-Gas Sensing Based on Portable Mid-Infrared Spectroscopy and PCA-BP Algorithm

Multiple Gas Detection Using V-cavity Coupled Diode Laser

Non-dispersive infrared multi-gas sensing via nanoantenna integrated narrowband detectors

Miniaturized CO2 Gas Sensor Using 20% ScAlN-Based Pyroelectric Detector

Mid-infrared cavity-enhanced absorption sensor for ppb-level N 2 O detection using an injection-current-modulated quantum cascade laser

Sensitive Carbon Monoxide Detection Based on Light Induced Thermoelastic Spectroscopy with a Hollow Waveguide and 2.3 Μm Diode Laser

Multiplex-Gas Detection based on Non-Dispersive Infrared Technique: A Review

Near-Infrared Off-Axis Integrated Cavity Output Spectroscopic Sensor System for Ammonia Leakage Measurement in Cold Store Using Embedded Multi-Core Processor

Design and optimization of an integrated MEMS gas chamber with high transmissivity

Ultra-compact dual-channel integrated CO2 infrared gas sensor