Abstract:With the development of 5G/6G communication, the requirements of portable devices for miniaturization and multifunction make low-temperature co-fired ceramic (LTCC) more and more important. In the area of high-frequency high-density passive integration, microwave dielectric ceramics with a low dielectric loss and high thermal conductivity are urgently needed to ensure the effective signals transmission and system reliability. However, most microwave dielectric ceramics with a low dielectric loss were not applicable for the LTCC technology due to the high sintering temperature. In this work, a series of MgO-based ceramics [(100 - x) wt.% MgO-x wt.% (0.2SrF(2)-0.8LiF) (x = 5,7,10)] were prepared by solid-state reaction method. The addition of sintering aid 0.2SrF(2)-0.8LiF (S2L8) decreased the sintering temperature below 880 degrees C without degrading the microwave dielectric properties of ceramics. Microwave dielectric properties of ceramics, including quality factor Q x f, relative permittivity epsilon(r), and temperature coefficient of resonant frequency tau(f), were investigated to find the optimum composition and sintering temperature. In general, MgO-7 wt.% S2L8 ceramic sintered at 860 degrees C exhibits outstanding properties of Q x f = 180 233 GHz, epsilon(r) = 9.11, tau(f) = -40.33 ppm/degrees C, and a high thermal conductivity of 24.02 W/(m K). This series of ceramics are suitable to be co-fired with Ag electrodes. With all those great properties, this series of MgO-based ceramics are expected to be the candidates for LTCC applications in 5G/6G technology.

MgTiO3-CaTiO3 Microwave Dielectric Ceramics for High-Performance Dielectric Resonator Antenna by Optimized Epoxy Gel Casting

Novel low-er MGa<sub>2</sub>O<sub>4</sub> (M = Ca, Sr) microwave dielectric ceramics for 5 G antenna applications at the Sub-6 GHz band

Microstructure and Dielectric Properties of Novel MgTiO3-x Wt% MgAl2O4 Microwave Dielectric Composite Ceramics

Unleashing the Potential of Mg2SiO4-based Ceramics for Millimeter-Wave Applications: Achieving Ultra-Low Loss with Enhanced Temperature Stability Through Heterovalent Ion Substitution

Novel ultra-low loss and low-fired Li8MgxTi3O9+xF2 microwave dielectric ceramics for resonator antenna applications

Sintering behavior of 0.95MgTiO3-0.05CaTiO3 ceramics with high densification, high Q and enhanced mechanical properties for 5G massive MIMO technology: Effect of particle gradation

MgTiO3/TiO2/MgTiO3: an Ultrahigh-Q and Temperature-Stable Microwave Dielectric Ceramic Through Cofired Trilayer Architecture

The Effects of TiO2 Addition on Microwave Dielectric Properties of Y3MgAl3SiO12 Ceramic for 5G Application

Preparation and properties of 0.79ZnAl2O4-0.21TiO2 microwave dielectric ceramics via digital light processing

Ti4+ Modified Mgzrnb2o8 Microwave Dielectric Ceramics With An Ultra-High Quality Factor

5G microstrip patch antenna and microwave dielectric properties of 4 mol%LiF–MgO–xwt%MTiO3 (M = Ca, Sr) composite ceramics

Enhanced Microwave Dielectric Properties and Sintering Behaviors of Mg2SiO4-Li2TiO3-LiF Ceramics by Adding CaTiO3 for LTCC and GPS Antenna Applications

Broadband and high-efficiency of garnet-typed ceramic dielectric resonator antenna for 5G/6G communication application

Temperature-stable Li4Ti3O8 composite microwave dielectric ceramic and its applications in dielectric resonator antennas

Microwave dielectric properties and phase evolution of Zn-excess Mg0.95Zn0.05+xTiO3+x (x = 0–0.1) ceramics

Ultra-high quality factor of Mg6Ti5O16-based microwave dielectric ceramics with temperature stability

High Q×f values of Zn-Ni co-modified LiMg0.9Zn0.1-xNixPO4 microwave dielectric ceramics for 5G/6G LTCC modules

Microwave Dielectric Properties of Mg1.8R0.2Al4Si5O18 (R = Mg, Ca, Sr, Ba, Mn, Co, Ni, Cu, Zn) Cordierite Ceramics and Their Application for 5G Microstrip Patch Antenna

Low‐temperature‐sintered MgO‐based Microwave Dielectric Ceramics with Ultralow Loss and High Thermal Conductivity

Temperature stable Li2Ti0.75(Mg1/3Nb2/3)0.25O3-based microwave dielectric ceramics with low sintering temperature and ultra-low dielectric loss for dielectric resonator antenna applications

Composite Dielectrics (1−x)(mg0.97zn0.03)2(ti0.95sn0.05)o4−xcatio3 Suitable for Microwave Applications