Abstract:With the continued device scaling and the introduction of new device structures, MOSFET reliability phenomena arising from the hot carrier injection (HCI) stress have received extensive attention from both the academia and the industry community. In this work, the degradations of ultra-scaled silicon on insulator (SOI) MOSFETs under the HCI stress are investigated on devices of different gate lengths (L=30-150 nm). Our experimental data demonstrate that the time evolutions of the threshold voltage change (Vth) under the HCI stress for different gate length devices are the same, and the magnitude of Vth reduces for the shorter devices. The degradation of the device under the HCI stress should be due to both the channel hot carrier (CHC) effect and the bias temperature instability (BTI) effect. The distribution and magnitude of the electric field along the MOSFET's channel are analyzed. It is confirmed that besides the well-known CHC effect in the depletion region close to the drain side, a strong BTI effect co-exists in the channel close to the source side. This degradation mechanism is different from the conventional HCI stress. With the gate length decreasing, the contribution of the aforementioned BTI effect becomes larger, and it dominates in the degradation. One feature of the BTI effects is that the corresponding degradation is small when the gate length is short. This is consistent with our experimental result that the change of Vth is small for the device of short gate length under the accelerated HCI stress. The time evolution of Vth can be described by the equation Vth=A•tn, where A is a constant, t is the stress time, and n is the power law exponent obtained by the curve fitting. In this study, the power law exponent n of pMOSFET is larger than that of nMOSFET. This experimental fact can lead to the point that the BTI effect exists during the HCI stress because the BTI effect in ultra-scaled pMOSFETs is more significant than that in nMOSFETs. The stress-recover experiments of the HCI stress on MOSFTTs show larger recovery in device of shorter gate length. It is found that the ratio of the recovery to the total degradation in the 30 nm gate-length device is almost twice as large as that in the 150 nm device. The degradation from the CHC effect has no recovery, and the larger recovery in the shorter-channel device implies the larger component of the BTI degradation. Another intriguing fact is that our experimental result on SOI MOSFET is inconsistent with the recently reported result on FinFET. We argue that the reported stronger HCI degradation in FinFET may not be ascribed only to the stronger electric field in the shorter channel, but also to the fact that the FinFET' channel is three-dimensionally surrounded by the gate dielectric. This kind of three-dimensional structure significantly increases the chance for electrons or holes to be injected into the dielectric layer. Therefore the HCI reliability of planar SOI MOSFETs may be better than that of FinFETs at the same level of gate length. In conclusion, the BTI effect is an important source of the degradation during the HCI stress in ultra-short-channel device, and it is no more negligible in analyzing the underlying physical mechanism.

Investigation of Heavy-Ions-Induced Leakage Current Modes and Degradation Mechanism in SiC MOSFETs under Complex Heavy Ion Conditions

Gate Oxide Damage of SiC MOSFETs Induced by Heavy-Ion Strike

Analysis of Gate Oxide Degradation Induced by Heavy Ion in SiC Power MOSFETs

Study on the Single-Event Burnout Effect Mechanism of SiC MOSFETs Induced by Heavy Ions

Heavy-ion induced gate damage and thermal destruction in double-trench SiC MOSFETs

Study of the Leakage Current Degradation Based on Stacking Faults Expansion in Irradiated SiC Junction Barrier Schottky Diodes

Heavy-ion effects in SiC power MOSFETs with trench-gate design

Investigation of Inrush Current Induced Trench Gate Degradation inside SiC MOSFET by New Fowler- Nordheim Localization Methodology

Heavy ion single event effect in double-trench SiC metal–oxide–semiconductor field-effect transistors

Heavy Ion Induced Electrical Property Degradation in Sub-100 Nm Bulk Silicon MOS Devices

Gate Length Dependence of Hot Carrier Injection Degradation in Short Channel Silicon on Insulator Planar Mosfet

Statistical analysis on performance degradation of 90 nm bulk Si MOS devices irradiated by heavy ions

The Degradation and Recovery of 1200-V SiC MOSFET with Different Total Ionizing Doses

Influence of LDD Spacers and H+Transport on the Total-Ionizing-Dose Response of 65-Nm MOSFETs Irradiated to Ultrahigh Doses

Total Ionizing Effects on Static Characteristics of 1200V SiC MOSFET Power Devices with Planar and Trench Structures

Degradation Behavior of SiC Trench MOSFETs by Total-Ionizing-dose Irradiation under Gate Voltage Stress

New Concerns on Heavy Ion Irradiation Induced Variation Degradation in Nanoscale CMOS Devices

Cut-Off Degradation of Output Current Induced by High Fluence Neutron Radiation in High-Voltage Silicon-on-Insulator Lateral Double-Diffused MOSFET

Degradation Evaluation and Defects Analysis for 1.2-kV Planar-Gate SiC MOSFETs Under Repetitive Surge Current Stress

Understanding the Degradation of 1.2-kV Planar-Gate SiC MOSFETs Under Repetitive Over-load Current Stress

Heavy-ion-induced permanent damage in ultra-deep submicron fully depleted SOI devices