Abstract:Ethylene glycol (EG) and water mixtures can be used as the antifreeze, refrigerant and coolant due to their good environmental, thermodynamic and transport performance. The mixture's accurate thermal conductivity is indispensable for the optimal design of the relevant heat exchangers. However, thermal conductivity of EG/water mixtures is lacking and is seen to limit the further industrial application. In this paper, the transient hot wire method (THW) was used to measure the thermal conductivities of five EG/water mixtures (with ethylene glycol mass fraction w EG = 0, 0.25, 0.50, 0.75, 1.00) in the temperature range from 253.15 K to 353.15 K and pressures up to 8.0 MPa. A comparison was made between the present experimental data and literature values, yielding a good agreement. The AADs are within 2.65% for EG/water mixture systems. For convenience of engineering calculations, the present experimental data were correlated as a function of temperature and pressure. The average absolute deviations (AADs) between the experimental thermal conductivities and the calculations are 0.50%, 0.10%, 0.60%, 0.40% and 0.32% for mixture systems with ethylene glycol mass fraction w EG = 0.00, 0.25, 0.50, 0.75, 1.00, respectively. In addition, non-equilibrium molecular dynamics was applied to study the thermal conductivities of ethylene glycol/water binary mixtures based on PCFF (polymer consistent force field) and SPC/E (extended simple point charge) model, showing a good agreement with the experimental data. This study can provide fundamental thermal conductivity data for the heat transfer application of ethylene glycol aqueous solution in the industrial field.

Measurement and modeling of liquid thermal conductivity of linear siloxanes: Octamethyltrisiloxane (MDM) and Hexamethyldisiloxane (MM)

Investigation on thermal conductivity of decamethylcyclopentasiloxane (D5) and decamethyltetrasiloxane (MD2M) in the liquid phase

Experimental and Simulation Analysis of Siloxane Mixtures Used in Organic Rankine Cycle with Thermal Stability Limits

Isobaric Heat Capacity Measurements for Dimethyl Ether and 1,1-Difluoroethane in the Liquid Phase at Temperatures from 305 K to 365 K and Pressures Up to 5 Mpa

Experimental Heat Transfer Coefficients for Zeotropic Mixture Condensation of Hexamethyldisiloxane/Octamethyltrisiloxane and Ethanol/Hexamethyldisiloxane

Thermal Stability and Material Compatibility for Hexamethyldisiloxane As the Working Fluids of Organic Rankine Cycle

Measurement of thermal conductivities of [mmim]DMP/CH3OH and [mmim]DMP/H2O by freestanding sensor-based 3ω technique

Thermal conductivity measurement of submicrometer-scale silicon dioxide films by an extended micro-Raman method

Measurement of Thermal Conductivity for Systems of Methyl Ethyl Ketoxime with Methyl Ethyl Ketone and N-Hexane Separately

Measurement of the Thermal Transport Properties of Dielectric Thin Films Using the Micro-Raman Method

Research On Thermal Conductivity Measurement Of Submicrometer-Scale Silicon Dioxide Film In Thermal Flow Sensor By Micro-Raman Technique

A ReaxFF-based molecular dynamics study of the pyrolysis mechanism of hexamethyldisiloxane

Density, Viscosity, and Vapor Pressure of 1,1,3,5,5-Pentamethyl-3-phenyltrisiloxane, 3-(Dimethylsilyloxy)-1,1,5,5-tetramethyl-3-phenyltrisiloxane, and 1,1,5,5-Tetramethyl-3,3-diphenyltrisiloxane

Experimental and Theoretical Research on the Saturated Liquid Thermal Conductivity of HFO-1336mzz(E)

Equivalence of the Equilibrium and the Nonequilibrium Molecular Dynamics Methods for Thermal Conductivity Calculations: from Bulk to Nanowire Silicon

Thermal conductivity measurements for n-hexane and n-heptane at elevated temperature and pressure

Thermal conductivity calculations of binary liquid organic mixtures by molecular dynamics simulation and its interpretation of microscopic heat transfer mechanism

Investigation on liquid thermal conductivity of ethylene glycol (EG)/water mixtures: A comparative experimental and molecular dynamics simulation study

Measurement and Thermodynamic Models for Ternary Liquid–Liquid Equilibrium Systems {Water + Polyoxymethylene Dimethyl Ethers +4-Methyl-2-pentanol} at Different Temperatures

Experimental and Theoretical Studies of Effective Thermal Conductivity of Composites Made of Silicone Rubber and Al2o3 Particles

Molecular Dynamics Investigation Of The Slip Flow Liquid-Solid Interfacial Thermal Conductance