Abstract:The pre-bored grouted planted (PGP) pile is a composite pile consisting of a precast concrete pile and the cemented soil around the pile. Thus, the PGP pile shaft capacity is affected by the pile–cemented soil interface and the strength of the cemented soil formed around the pile. In this paper, a series of shear tests were conducted to investigate the frictional capacity of the precast concrete pile–cemented soil interface, and the strength of cemented soil and its effect on the interface frictional capacity. The test results show that the frictional capacity of precast pipe pile–cemented soil interface is largely dependent on the cemented soil strength, and the peak skin friction of the interface increases from 7.58 to 204 kPa with the cemented soil strength increasing from 65 to 1500 kPa. An adhesion factor is proposed to correlate the peak skin friction of the precast pipe pile–cemented soil interface and cemented soil strength. The adhesion factor is found to range from 0.116 to 0.141 corresponding to the range of cemented soil strength from 65 to 1500 kPa. It was also noted the failure at the pile–cemented soil interface is brittle. The scale effect also exists in the pile–cemented soil interface shear test, and the scale effect factor is 1.9 when the pile diameter decreases from 85 to 37 mm. Accordingly, the design of PGP pile should avoid approaching the frictional capacity of the pile–cemented soil interface.

Experimental Study on Friction Capacity of Pile-Stabilized Soil Interface

Laboratory tests on the frictional capacity of core pile - cemented soil interface

The Effect of Cemented Soil Strength on the Frictional Capacity of Precast Concrete Pile–cemented Soil Interface

Experimental Study on Behavior of Composite Foundation with Rigid-Flexible Piles

Effect of Cemented Soil Properties on the Behavior of Pre-Bored Grouted Planted Nodular Piles under Compression

In-situ Experiment on Urban Road Subgrade Improved by Plain Concrete Pile and Mixed-in-place Pile

Experimental study on frictional capacity of square pile-cemented soil interface

Test Research on the Behavior of Composite Foundations Incorporating Rigid and Flexible Piles

Shaft Capacity of the Pre-Bored Grouted Planted Pile in Dense Sand

Settlement of composite ground reinforced by deformable piles

Testing and Modeling the Behavior of Pre-Bored Grouting Planted Piles under Compression and Tension

Field Tests on Behavior of Pre-Bored Grouted Planted Pile and Bored Pile Embedded in Deep Soft Clay

Model tests comparing the behavior of pre-bored grouted planted piles and a wished-in-place concrete pile in dense sand

The frictional capacity of smooth concrete pipe pile–cemented soil interface for pre-bored grouted planted pile

Field Tests on Behavior of Pre bored Grouted Planted Pile in Soft Soil Area with Existing Pile Foundation

Influence of Soil Reinforcement on the Uplift Bearing Capacity of a Pre-Stressed High-Strength Concrete Pile Embedded in Clayey Soil

Field Behavior of Pre-Bored Grouted Planted Nodular Pile Embedded in Deep Clayey Soil

Experimental study on the frictional capacity of square pile–cemented soil interface with different surface roughness

Field Test on the Influence of the Cemented Soil Around the Pile on the Lateral Bearing Capacity of Pile Foundation

Field study on the behavior of pre-bored grouted planted pile with enlarged grout base

A Simplified Nonlinear Calculation Method to Describe the Settlement of Pre-Bored Grouting Planted Nodular Piles