Abstract:<p>With increasing desires to protect the environment, volatile organic solvent emissions have been restricted, and there is a trend in developing waterborne polyurethanes. However, poor water resistance and low mechanical strength of waterborne polyurethane are major obstacles. Herein, we propose a terpene-modified polysiloxane-based polyurethane that solves the above-stated problems. In the presence of the Karstedt catalyst, isobornyl acrylate (IBOA) was introduced into the branch of hydrogen-containing silicone oil (HSO) through the hydrosilylation reaction. Then, it was mixed with an alkaline aqueous solution to convert the remaining SiH bonds to Si−OH bonds, which can be used as a polyol component (IBOA-Si-OH). Then, the mixtures of IBOA-Si-OH and polypropylene glycol-400 (PPG-400) were used as polyol components to react with polyisocyanate-3100 (PI-3100) in preparing a two-component waterborne polyurethane. Compared with the unmodified polyurethane film, the contact angle of the polyurethane film modified with IBOA-Si-OH was greater than 102°, which increased by 28°. The water absorption test showed that the modified polyurethane membrane nearly doubled its ability to prevent water penetration (from 18.11 % to 9.38 %). Although the introduction of silicone improved the water resistance of waterborne polyurethane, the mechanical properties were reduced. The introduction of IBOA into the silicone side chain improved the mechanical properties of polyurethane. Comparing WPU-Si with WPU-2, the tensile strength improved by 85.56 % (from 3.47 MPa to 6.44 MPa). Thermogravimetric analysis and dynamic thermomechanical analysis indicated that silicone reduced T<sub>g</sub> and thermal stability, but participation of IBOA made up for this deficiency. Terpene biobased compounds have great potential and application prospects in the modification of polymer materials.</p>

Preparation and properties of organosilicon-polyurea composites

Synthesis and Characterization of Eugenol‐based Silicone Modified Waterborne Polyurethane with Excellent Properties

Silica/polyimide Hybrids and Their Dielectric Properties. I. Preparation with an Improved Sol–gel Process with Poly(amic Acid) As the Precursor

Synthesis of CO2-Derived, Siloxane-Functionalized Poly(ether Carbonate)s and Waterborne Polyurethanes

Synthesis, characterization and lubricating effect of long chain branched polydimethylsiloxane-g-polyethylene copolymers

Preparation and Performance of Silicone Rubber Composites Modified by Polyurethane

Preparation and Research of Hydrophobic PDMS/Nano-SiO2 Modified SiO2 Coating

Acrylic‐Based Polyurethane/Silica Hybrids Prepared by Acid‐Catalyzed Sol–Gel Process: Structure and Mechanical Properties

Preparation and Characterization of Silicone Oil Modified Polyurethane Damping Materials

A new organosilicon adhesive based on polysiloxane and polysilazane

Synthesis and Properties of Nanosilica‐reinforced Polyurethane for Grouting

Preparation and Properties of Advanced Materials for Bi-component Polyurethane Adhesives Containing Siloxane.

Preparation and Application of UV Curable Waterborne Organosilicon Acrylic Polyurethane with Controllable Silicon Content

Structure and Properties of Polyurethane/nanosilica Composites

Epoxy-silicone copolymer synthesis via efficient hydrosilylation reaction catalyzed by high-activity platinum and its effect on structure and performance of silicone rubber coatings

Preparation and Surface Properties of Silicone-Modified Polyester-Based Polyurethane Coats

Preparation of organosilicon and organofluorine synergistically modified amphiphilic branched polyurethanes and their application in diisocyanate emulsifiers

Terpene derivative-containing silicone two-component waterborne polyurethane for coatings

Partial crystalline organosilicon-based polysiloxane-polyurethane copolymers

Preparation and properties studies of UV-curable silicone modified epoxy resin composite system

The synthesis and research of a novel organosilicon-modified waterborne blocked polyisocyanate crosslinker with a semi-interpenetrating network structure