Abstract:Wet flue gas desulfurization (WFGD) wastewater treatment is a key problem in coal-fired plants. Traditional chemical precipitation methods cannot reach zero-liquid discharge (ZLD). In this paper, a new technology using the low-rank heat from flue gas to concentrate the wastewater for ZLD is proposed. A scrubber was built to verify the concentrating process, and the characteristics of the concentrated water were analyzed. The concentrated water was neutralized by adding Ca(OH)2 to raise the pH value. The wastewater can be concentrated 10~25 times to reduce the flow rate. The characteristics of the concentrated wastewater were studied by dosing lime. Then, liquid and solids were separated by filter pressing, the liquid was mainly composed of CaCl2, which accounts for 73.6%. The sludge is composed of CaSO4 and Mg(OH)2, depending on the lime consumption of the dosing process. Finally, the filter liquor after the filter press was mixed with ash to reach zero liquid discharge, and the sludge could be burnt after mixing with the coal or disposed by third-part vendor. This technology is demonstrated in one 600 MW unit and shows a high system reliability. The clean water is recycled by the WFGD wastewater during the evaporation. Binding on the environmental policies and large market demand of the WFGD wastewater, this technology shows a great application prospect in the future.

EXPERIMENTAL RESEARCH OF WET LIQUID-COLUMN FLUE GAS DESULFURIZATION SYSTEM

A Semi-Wet Technological Process for Flue Gas Desulfurization by Corona Discharges at an Industrial Scale

Streamer Plasma Induced Ammonia Flue Gas Desulfurization

Experimental Study of Wet Flue Gas Desulphurization of Impinge Liquid Column Tower

Application and experimental investigation of compound additive enhanced wet flue gas desulfurization process

Experimental Study on the Cfb-Fgd of Semi-Dry Process in A Demo Plant

Operating experience of CFB semi-dry FGD with novel humidification technology in China

TECHNOLOGY OF WET DESULFURIZATION OF FLUE GAS

Experimental Study of Semi-dry Flue Gas Desulfurization in Circulating Suspension Fluidized Bed

STUDY ON DESULFURIZATION CHARACTERISTIC IN CaO ACTIVATION REACTOR OF LIMESTONE INJECTION FGD SYSTEM --EXPERIMENTAL RESULTS AND DISCUSSION

Research on wet flue gas desulfurization by waste

EXPERIMENTAL STUDY AND INDUSTRIAL APPLICATION OF TURBULENT FLOW TYPE WET FLUE GAS DESULFURIZATION AND DUST-EIMINATION TECHNOLOGY

Experimental Research on the CFB-FGD of Semi-Dry Process in Ambient Temperature in a Demo Plant

Experimental Study on Desulfurization Efficiency and Gas–liquid Mass Transfer in a New Liquid-Screen Desulfurization System

Experimental Study of Limestone/Gypsum-based Wet Process Flue Gas Desulfuration

Experimental research on a wet flue-gas desulfurization method by falling film

Performance Optimization of Wet Flue Gas Desulphurization System Based on CFD Technology

New Liquid-column FGD and Dedust System in Shenyang Fertilizer Factory

Primary Research of a New Zero-Liquid-Discharge Technology of Wet Flue Gas Desulfurization Wastewater by Low-Rank Heat from Flue Gas

D306 EXPERIMENTS AND MATHEMATICAL MODEL ON FLUE GAS DESULFURIZATION OF CIRCULATING FLUIDIZED BED

Industrialization experimental study on technology of double circulating fluidized bed flue gas suspend desulfurization