Abstract:TiO2 thin films were deposited on polymer substrates (polyethylene terephthalate and polystyrene) at low substrate temperature (< 120 degrees C) from radiofrequency inductively coupled O-2/titanium tetraisopropoxide (TTIP) plasmas. The film growth was tuned by controlling the O-2/TTIP flow rate ratio and pulsing the plasma power. The nanostructure including the film morphology and crystallization was thoroughly characterized by transmission electron microscopy. The photocatalytic activity was evaluated by measuring the degradation rate of methylene blue under UV light irradiation. All the films exhibit columnar morphologies. Increasing the O-2/TTIP ratio from 97:3 to 98.5:1.5 in the plasma leads to an increase in the column size and the amount of anatase phase. Meanwhile the photocatalytic activity was also improved. Then keeping the same O-2/TTIP ratio of 98.5:1.5, the substrate temperature was decreased even lower than 80 degrees C by pulsing the plasma with the duty cycle of 50%, which allows the deposition on the polystyrene substrate. In this pulsed mode, the column size is reduced, and the bottom layer (around 0-200 nm) near the substrate contains less anatase phase, but as the thickness increased, the anatase phase can be gradually enhanced in the upper layer (around 200-300 nm). Moreover, these films grown in the pulsed mode at low temperature (< 80 degrees C) present a high photocatalytic activity which indicates the film upper layer plays a more significant role in the photodegradation of methylene blue.

Preparation of Photo-Catalysis TiO_2 Films by Combined Plasma Surface Treatment

Controllable Hydrothermal Synthesis, Optical and Photocatalytic Properties of TiO2 Nanostructures

Influence of V5+ Ions on Photocatalytic Activity of TiO2 Films Prepared by Micro-plasma Oxidation Method

Phenol Degradation by TiO2 Photocatalysts Combined with Different Pulsed Discharge Systems.

Oxidation Conditions of Ti and Photocatalysis of TiO2 Ceramic Films

TiO2 films prepared by DC reactive magnetron sputtering at room temperature: Phase control and photocatalytic properties

Black TiOx Films with Photothermal-Assisted Photocatalytic Activity Prepared by Reactive Sputtering

Photocatalytic performance of plasma sprayed TiO2-ZnFe2O4 coatings

Growth kinetics and crystallization behavior of TiO2 films prepared by plasma enhanced atomic layer deposition

Water-plasma-enabled Surface Tailoring of Faceted TiO2 for Versatile Photocatalytic Applications

Fabrication of Porous Tio2 Film Via Hydrothermal Method and Its Photocatalytic Performances

Characterization and Photocatalytic Activity of Tio2 Films Loaded on Different Substrates

Preparation and photo-catalytic properties of nanostructured TiO2 thin films coated on different ceramics

TEM Analysis of Photocatalytic TiO2 Thin Films Deposited on Polymer Substrates by Low-Temperature ICP-PECVD

Water-plasma-enabled surface tailoring of faceted TiO 2 for versatile photocatalytic applications

Effects of heat treatment on the microstructure and properties of TiO2 based film by plasma electrolytic oxidation

A Study Of Titanium Oxide Film Electrodes Prepared By Direct Thermal Oxidation - Ii. Photoelectrochemical Performance

Synthesis of porous TiO 2 and Fe-doped TiO 2 films for photocatalysis by a cooling enhanced plasma electrolytic oxidation approach

Improved Photocatalytic Performance via Air-Plasma Modification of Titanium Dioxide: Insights from Experimental and Simulation Investigation

Non-thermal Plasma-Induced Photocatalytic Degradation of 4-Chlorophenol in Water.

The Preparation and Chemical Structure of Tio2 Film Photocatalyst Supported on Stainless Steel Using the Sol-Gel Method