Abstract:The backflow power in dual-active bridge (DAB) converters can cause power circulation in the H-bridge instead of flowing to the load, which increases the power loss of switching devices and magnetic components and lowers the system's efficiency. Hence, a unified optimal modulation strategy (UOMS) is proposed in this article to reduce the backflow power and consequently improve the system efficiency. However, there is a conflict between minimizing the backflow power and achieving the zero-voltage-switching (ZVS) conditions of all the switching devices. Hence, a regulatory factor " gamma" is introduced into the control variables to minimize the backflow power on the premise of all ZVS conditions, and hence, comprehensively improve the system efficiency. Moreover, the regulatory factor " gamma" simplifies the calculation form of the control variables, which is easier to perform in the controller and can effectively shorten the computational time. According to the value ranges of the control variables (D-0, D-1, and D-2) in the proposed UOMS, 12 operating modes are classified and four effective modes are detailed. For the four effective modes, the optimal triple-phase shift (TPS), optimal primary-dual-phase shift (PDPS), and optimal secondary-dual-phase shift (SDPS) modulation strategies are derived and their switching relationships are revealed. With various transferred powers, the proposed UOMS combines the optimal TPS, PDPS, SDPS, and SPS modulation strategies and can realize smooth and seamless transition switching processes among them in the full operating range. Therefore, the DAB converter can always operate in the optimal states for the full operating range of both the "Buck Mode" (k > 1) and "Boost Mode" (k < 1). Finally, experimental results verify the correctness of the theoretical analysis and the effectiveness of the proposed UOMS.

The Impact of Periodic Variable Switching Frequency Modulation on Power Transmission in Dual-Active-Bridge Converter and an Improved Scheme

ZVS Operation of DAB Converter Based on Triple-Phase-shift Modulation Scheme with Optimized Inductor Current

Variable Switching Periods Based Space Vector Phase-Shifted Modulation for DAB Based Three-Phase Single-Stage Isolated AC–DC Converter

Variable Frequency Phase-Shift Modulation Technique for Single Stage Dual-Active-Bridge AC-DC Converter

An Analog-based, Duty Cycle Modulation Method to Remove the DC Bias in the Transformer for a Dual Active Bridge Converter

A Partial-Variable-frequency Modulation Scheme for DAB Converter for the All-Zvs Operation in the Full Power Range

Research on Optimum Extended Phase-Shift Control with Minimum Peak-to-peak Current of DAB Converter Applied to Small DC Power Grid

Overview of Multi-Degree-of-Freedom Modulation Techniques for Dual Active Bridge Converter

Hybrid spread spectrum modulation-based electromagnetic interference suppression of vehicle DC/DC converters

Elimination of High Frequency Oscillation in Dual Active Bridge Converters by Dv/dt Optimization.

Time-Varying Full-Order State-Space Modeling of Variable-Switching-Frequency Control for Single-Phase Single-Stage Dual-Active-Bridge Based Ac/Dc Converter

A Novel Light Load Performance Enhanced Variable-Switching-Frequency and Hybrid Single-Dual-Phase-Shift Control for Single-Stage Dual-Active-Bridge Based Ac/Dc Converter

Improved Active Disturbance Rejection Control for the DAB Converter with 4-DF Modulation

A Unified Optimal Modulation Strategy for DAB Converters to Tradeoff the Backflow Power Reduction and All ZVS in the Full Operating Range

Extension of Zero-Voltage Switching Region of Wide Volage Ratio Range Dual-Active-Bridge Converter by LC Antiresonant Network

Loss Imbalance and Transient DC-Bias Mitigation in Dual-Active-Bridge DC/DC Converters

A Collaborative Modulation Method of Dual-Side Backflow Power Optimization and Zero-Voltage Switching for Dual Active Bridge

Simplified Fixed Frequency Phase Shift Modulation for A Novel Single-Stage Single Phase Series-Resonant AC-DC Converter

Variable Switching Frequency for ZVS over Wide Voltage Range in Dual Active Bridge

Generalized Multi-Phase-Shift Transient Modulation for Dual-Active-Bridge Series-Resonant Converter

A Unified Optimal Modulation Strategy for DAB Converters to Trade-off the Backflow Power Reduction and All ZVS in the Full Operating Range