Abstract:The backflow power in dual-active bridge (DAB) converters can cause power circulation in the H-bridge instead of flowing to the load, which increases the power loss of switching devices and magnetic components and lowers the system's efficiency. Hence, a unified optimal modulation strategy (UOMS) is proposed in this article to reduce the backflow power and consequently improve the system efficiency. However, there is a conflict between minimizing the backflow power and achieving the zero-voltage-switching (ZVS) conditions of all the switching devices. Hence, a regulatory factor " gamma" is introduced into the control variables to minimize the backflow power on the premise of all ZVS conditions, and hence, comprehensively improve the system efficiency. Moreover, the regulatory factor " gamma" simplifies the calculation form of the control variables, which is easier to perform in the controller and can effectively shorten the computational time. According to the value ranges of the control variables (D-0, D-1, and D-2) in the proposed UOMS, 12 operating modes are classified and four effective modes are detailed. For the four effective modes, the optimal triple-phase shift (TPS), optimal primary-dual-phase shift (PDPS), and optimal secondary-dual-phase shift (SDPS) modulation strategies are derived and their switching relationships are revealed. With various transferred powers, the proposed UOMS combines the optimal TPS, PDPS, SDPS, and SPS modulation strategies and can realize smooth and seamless transition switching processes among them in the full operating range. Therefore, the DAB converter can always operate in the optimal states for the full operating range of both the "Buck Mode" (k > 1) and "Boost Mode" (k < 1). Finally, experimental results verify the correctness of the theoretical analysis and the effectiveness of the proposed UOMS.

A Unified Optimal Modulation Strategy for DAB Converters to Tradeoff the Backflow Power Reduction and All ZVS in the Full Operating Range

A Unified Optimal Modulation Strategy for DAB Converters to Trade-off the Backflow Power Reduction and All ZVS in the Full Operating Range

ZVS Operation of DAB Converter Based on Triple-Phase-shift Modulation Scheme with Optimized Inductor Current

A Unified Design Approach of Optimal Transient Single-Phase-Shift Modulation for Nonresonant Dual-Active-Bridge Converter with Complete Transient DC-Offset Elimination

Wide-Load Range Multiobjective Efficiency Optimization Produces Closed-Form Control Solutions for Dual Active Bridge Converter

Unified ZVS Strategy for DAB with Triple-Phase-shift Modulation in Boost Mode

Multi-Objective Optimization Method Based on Double-Side Asymmetrical Modulation Scheme for DAB-Based DC-DC Converter

Analysis and Optimal Modulation for 2/3-Level DAB Converters to Minimize Current Stress with Five-Level Control

A Collaborative Modulation Method of Dual-Side Backflow Power Optimization and Zero-Voltage Switching for Dual Active Bridge

Globally Unified ZVS and Quasi-Optimal Minimum Conduction Loss Modulation of DAB Converters

A Comprehensive Optimization Strategy of DAB Converter with Minimal Current Stress and Full Soft-Switching in the Whole Operating Range

Optimal Control of Multi-Level DAB Converters for Soft-Switching and Minimum Current Stress

Optimal Dual-Side Asymmetric Modulation Strategy for Dual Active Bridge Converter to Improve Efficiency over a Wide Voltage Range

A Partial-Variable-frequency Modulation Scheme for DAB Converter for the All-Zvs Operation in the Full Power Range

A Dynamic ZVS-Guaranteed and Seamless-Mode-Transition Modulation Scheme for the DAB Converter That Maximizes the ZVS Range and Lowers the Inductor RMS Current

Bidirectional ZVS Operation of All Switches for a DAB Converter Over a Full Range of Loads With Optimized Current Stress

An Optimized Modulation Strategy for the Three-Level DAB Converter With Five Control Degrees of Freedom

Smooth Closed-loop Control Strategy Design for Dual-Active Bridge Converters Using Optimized TPS Modulation

Optimized Modulation Scheme of Dual Active Bridge DC-DC Converter Based on Triple-Phase-Shift Control

Hybrid control of ISOP-DAB converters based on double-loop decoupling

Unilateral Asymmetric Triple Phase Shift Modulation Strategy for DAB Converter Compromising RMS Current and Soft-Switching Range