Abstract:As MOSFET devices are scaled down to below 100nm, the gate oxide thickness is required below 2nm. Conventional SiO2 gate dielectric will be replaced due to excessive leakage and poor reliabilit y. Thus, high dielectrics constant (K) gate dielectrics are being studied as an alternative. High-K dielectrics materials such as CeO2, Y2O3, Ta2O5, HfO2, ZrO2, TiO2, Al2O3, SrTiO3(STO), and BaSrTiO3(BST) have are studied . Among them, HfO2 is a promising candidate due to its thermodynamic stabil ity on Si, high dielectric constant ( 25), and relatively large band gap (5.68eV). In the paper, ultra-thin HfO2 gate dielectrics films were fabricated, electrical and reliabili ty properties such as capacitance-voltage (C-V), current-voltage (I-V), stress induce leakage current (SILC) effects and breakdown characteristics were studied. In the experiment, HfO2 capacitor samples have been fabricated using the following process. P-type (100) sili con substrates with 5-8 cm resistivity were cleaned using H2SO4:H2O2 (2:1) solution and HF dip. Thin HfO2 layers were following deposited at room temperature by ion beam sputtering a sintered HfO2 target. Then they were annealed under various temperatures and ambient. After annealing, Pt top electrodes were deposited by sputtering. The area of the capacitors was 5 10cm. The C-V and I-V curves were measured using HP4156B semiconductor parameter analyzer and Keithley590 C-V analyzer. Figure 1 shows the capacitance-voltage (C-V) curves of HfO2 gate dielectrics. The largest value of measured capacitance density in accumulation is Cmax/A=11.6fF/ m. The equivalent oxide thickness (EOT) is about 2.9nm. Comparing capacitances of various annealing temperatures, the capacitance of the sample annealed at 400 is highest. With increase annealed temperatures, EOT increased. Figure 2 shows the current-voltage (I-V) characteristics of HfO2 gate dielectrics. The leakage current of the sample annealed at 800 is lowest, which is about 3.09 10A/cm at –1.5V gate voltage. No distinct SILC effect is obtained. The leakage current of the sample annealed at 400 after 1×10C/cm stress has a very lit tle diversification. With increase annealed temperatures, the leakage current and SILC effect reduced. Figure 3 shows breakdown characteristics of HfO2 dielectrics. The breakdown electric field of HfO2 dielectrics is more than 2×10MV/cm. With increase annealing temperatures, the breakdown voltages decreased. Consequently, ultra-thin HfO2 gate dielectrics (EOT<3nm) were fabricated. All samples annealed under various temperatures and N2 ambient have good electrical characteristic and reliabili ty. With increase annealing temperatures, EOT of increased, the leakage current and SILC effect reduced, the breakdown voltages decreased. References: [1] E.P. Gusev, E. Carier, D.A. Buchanan, M. Gribelyuk, M. Copel, H. Okorn-Schmidt, and C.D. Emic, Microelectronic Engineering 59(2001) 341-349 [2] Wen-jie Qi, Renee Nieh, Byoung Hun Lee, Laegu Kang, Yongjoo Jeon, and Jack C. Lee, Applied Physics Letters, 2000, 77(20): 3269-3271 [3] G.D. Wilk, and R.M. Wallace, Applied Physics Letters, 1999, 74(19): 2854-2856 [4] Kevin X. Zhang, Carlton M. Osbun, IEEE Trans. Electron Devices, 42(12), 1995, 2181-2188 [5] G.D. Wilk, R.M. Wallace, J.M. Anthony, Applied Physics Review, 2001, 89(10): 5243-5275

Electrical Characterization of HfO2/4H-SiC and HfO2/Si MOS Structures

Analysis of the Electrical Properties and Current Transportation Mechanism of a Metal Oxide Semiconductor (MOS) Capacitor Based on HfGdO Gate Dielectrics

Comparison of Microstructure and Electrical Characteristics of Sputtering-Derived HfGdO/HfTiO and HfTiO/HfGdO Gate Stacks

Electronic Properties of ZrO2 Films Fabricated via Atomic Layer Deposition on 4H-SiC and Si Substrates

Interface Properties Study on SiC MOS with High-K Hafnium Silicate Gate Dielectric

Electronic properties of ZrO<sub>2</sub> films fabricated via atomic layer deposition on 4H-SiC and Si substrates

Reliability characteristics of high-K gate dielectrics HfO2 in metal-oxide semiconductor capacitors

Saturation Thickness of Stacked SiO2 in Atomic-Layer-deposited Al2O3 Gate on 4H-Sic

Improved electrical characteristics of 4H-SiC (0001) MOS devices with atomic layer deposited SiO2 gate dielectric with H2O plasma

C-V and J-V Investigation of HfO2/Al2O3 Bilayer Dielectrics MOSCAPs on (100) Β-Ga2o3

High-k gate stack Hf x Ti1−x ON/SiO2 for SiC MOS devices

The Electrical Characteristics of A 4H-Silicon Carbide Metal-Insulator-Semiconductor Structure with Al2o3 As the Gate Dielectric

Scalability And Reliability Characteristics Of Cvd Hfo2 Gate Dielectrics With Hfn Electrodes For Advanced Cmos Applications

Leakage Current Behavior in HfO2/SiO2/Al2O3 Stacked Dielectric on 4H-SiC Substrate

Investigation of a 4H—SiC metal—insulation—semiconductor structure with an Al2O3/SiO2 stacked dielectric

Electrical and Reliability Characteristics of High-Κ HfO 2 Gate Dielectrics

Electrical Performance Improvement In Sio2/Hfsio High-K Gate Stack For Advanced Low Power Device Application

Temperature-dependent Fowler-Nordheim electron barrier height in SiO2/4H-SiC MOS capacitors

High-temperature time-dependent dielectric breakdown of 4H-SiC MOS capacitors

Electrical Characteristics of MOS Capacitor with HfTiON Gate Dielectric and HfTiSiON Interlayer

Characteristics of sub-1 nm CVD HfO/sub 2/ gate dielectrics with HfN electrodes for advanced CMOS applications