Abstract:Hydrothermal liquefaction technology (HTL) is a promising thermochemical method to convert biomass into novel liquid fuels. The introduction of oxides and inorganic acids/bases during the hydrothermal process significantly impacts the yield and composition of bio-oil. However, systematic research on their effects, especially at lower temperatures, remains limited. In this paper, we examine the effects of acidity and alkalinity on cotton stalk hydrothermal bio-oil by introducing homogeneous acids and bases. Given the operational challenges associated with product separation using homogeneous acids and bases, this paper further delves into the influence of heterogeneous oxide catalysts (possessing varying degrees of acidity and alkalinity, as well as distinct microstructures and pore architectures) on the production of cotton stalk hydrothermal bio-oil. The effects of nanoscale oxides (CeO2, TiO2, ZnO, Al2O3, MgO and SiO2) and homogeneous acid–base catalysts (NaOH, K2CO3, Na2CO3, KOH, HCl, H2SO4, HNO3) on the quality of cotton stalk bio-oil under moderate hydrothermal conditions (220 °C, 4 h) were investigated. Characterization techniques including infrared spectroscopy, thermogravimetric analysis, elemental analysis, and GC-MS were employed. The results revealed that CeO2 and NaOH achieved the highest bio-oil yield due to Ce3+/Ce4+ redox reactions, OH-LCC disruption, and ionic swelling effects. Nano-oxides enhanced the formation of compounds like N-ethyl formamide and aliphatic aldehydes while suppressing nitrogen-containing aromatics. The total pore volume and average pore width of oxides negatively correlated with their catalytic efficiency. CeO2 with low pore volume and width exhibited the highest energy recovery. The energy recovery of cotton stalk bio-oil was influenced by both acid and base sites on the oxide surface, with a higher weak base content favoring higher yields and a higher weak acid content inhibiting them. The findings of this research are expected to provide valuable insights into the energy utilization of agricultural solid waste, such as cotton stalks, as well as to inform the design and development of highly efficient catalysts.

Fractional Condensation and Aging of Pyrolysis Oil from Cotton Stalk

EXPERIMENTAL RESEARCH ON CORNCOB FAST PYROLYSIS FOR BIO-OIL IN A FLUIDIZED BED REACTOR

Fractional condensation of bio-oil vapors from pyrolysis of various sawdust wastes in a bench-scale bubbling fluidized bed reactor

Experimental Study on Biomass Pyrolysis in Fluidized Bed

Improved fast pyrolysis bio‐oils from straw and miscanthus by fractionated condensation

Coupling Effect of Pyrolysis Temperature and Condensing Temperature on the Enrichment of High Value-Added Phenolic Compounds in Bio-Oil from Pyrolysis of Crop Straw

Study on the properties and components of solid-liquid products by co-pyrolysis of sludge and cotton stalk

Preparation of bio-oil enriched with phenolic compounds by combining acid-washing pretreatment and condensation technology

Study on the Effect of Condensing Temperature of Walnut Shells Pyrolysis Vapors on the Composition and Properties of Bio-Oil

Investigation of Cotton Stalk-Derived Hydrothermal Bio-Oil: Effects of Mineral Acid/Base and Oxide Additions

RESEARCH ON BIOMASS PYROLYSIS AND BIO-OIL CHARACTERISTICS

An approach for upgrading biomass and pyrolysis product quality using a combination of aqueous phase bio-oil washing and torrefaction pretreatment

Experimental Study on the Composition Evolution and Selective Separation of Biomass Pyrolysis Vapors in the Four-Staged Indirect Heat Exchangers.

Effect of torrefaction and fractional condensation on the quality of bio-oil from biomass pyrolysis for fuel applications

Separation characteristics of biomass pyrolysis oil in molecular distillation

Pyrolysis Characteristics of Bio-Oil Fractions Separated by Molecular Distillation

Experimental Study of the Effect of Spray Medium on the Collection of Bio-Oil Produced from Biomass Fast Pyrolysis

Long Term Storage Stability of Bio-Oil from Rice Husk Fast Pyrolysis

EXPERIMENTAL RESEARCH ON CATALYTIC HYDROGENATION OF LIGHT FRACTION OF BIO-OIL

Further Separation, Characterization, and Upgrading for Upper and Bottom Layers from Phase Separation of Biomass Pyrolysis Oils

Separation of bio-oil by molecular distillation