Abstract:Half-Heusler alloys, which possess the advantages of high thermal stability, a large power factor, and good mechanical property, have been attracting increasing interest in mid-temperature thermoelectric applications. In this work, extra Zr-doped TiZrxNiSn samples were successfully prepared by a modified solid-state reaction followed by spark plasma sintering. It demonstrates that extra Zr doping could not only improve the power factor on account of an increase in the Seebeck coefficient but also suppress the lattice thermal conductivity originated from the strengthened phonon scattering by the superlattice nanodomains and the secondary nanoparticles. As a consequence, an increased power factor of 3.29 mW m–1 K–2 and a decreased lattice thermal conductivity of 1.74 W m–1 K–1 are achieved in TiZr0.015NiSn, leading to a peak ZT as high as 0.88 at 773 K and an average ZT value up to 0.62 in the temperature range of 373–773 K. This work gives guidance for optimizing the thermoelectric performance of TiNiSn-based alloys by modulating the microstructures on the secondary nanophases and superlattice nanodomains.The Supporting Information is available free of charge at https://pubs.acs.org/doi/10.1021/acsami.1c14723.Disorder scattering parameter, Rietveld refinement of XRD data, temperature-dependent thermoelectric performance of the TiNiSn-based samples, SEM images of the freshly fractured surface with different scales for TiZrxNiSn (x = 0, 0.005, 0.015, 0.025) samples, local grain size statistics of the TiZr0.015NiSn sample, EDS mapping images of the TiZr0.015NiSn sample, GEM approach, and SKB modeling and Debye–Callaway model simulation (PDF)This article has not yet been cited by other publications.

Crystallization Properties and Structural Evolution of Amorphous Ti-doped Sn20Sb80 Thin Layers Induced by Heating and Irradiating

Microstructure Optimization and Optical and Interfacial Properties Modulation of Sputtering-Derived Hfo2 Thin Films by Tio2 Incorporation

The Thermal Analysis, Crystal Growth And Structure Transformation Of Nano-Scale Tio2 Prepared By Ticl4 Hydrolysis

Investigation of microstructure evolution in Pt-doped TiO2 thin films deposited by rf magnetron sputtering

The Structure Change and the Superhydrophilicity of the Sb-Doped Titanium Dioxide Thin Films

Crystallization of Amorphous Titania Gel by Hot Water Aging and Induction of in Vitro Apatite Formation by Crystallized Titania

Effect of Zr, Hf, and Sn Additives on Elastic Properties of Α2-Ti3al Phase by First-Principles Calculations

Physical Properties and Structure Characteristics of Titanium-Modified Antimony-Selenium Phase Change Thin Film

Simultaneously achieving high performance of thermal stability and power consumption via doping yttrium in Sn15Sb85 thin film

Influence of samarium modification on the phase-change performance and phase structure of tin antimonide

Impact of Multiple Interfaces on the Thermal Annealing of Sb70Se30/Ti Thin Films

Microstructure Evolution and Crystallography of the Phase-Change Material TiSbTe Films Annealed in Situ

EFFECT OF CRYSTALLINE PHASE FORMATION ON OPTICAL PROPERTIES OF TiSi2 THIN FILMS

Impact of titanium modification on the performance improvement and phase change mechanism of ZnSb thin film

The Crystal Structure, Microhardness and Thermal Stability of the Ti26Al55Zn19 Alloy

Crystallization behavior of amorphous phase in the Ti-Ni-Ta surface alloy synthesized on TiNi substrate by electron-beam method

High-temperature transformation behavior of iron-doped titanium dioxide crystal structures

Why Sn Doping Significantly Enhances the Dielectric Properties of Ba(Ti 1-X Snx)O3.

Strategy of Extra Zr Doping on the Enhancement of Thermoelectric Performance for TiZr x NiSn Synthesized by a Modified Solid-State Reaction

Microstructure Evolution of the Phase Change Material Tisbte

Insight into the recrystallization behavior and precipitation reaction of in-situ nano TiB2/Al Cu Mg composite during heat treatment