Abstract:Mechanical behaviors of a Ni-based single crystal superalloy have been investigated by tensile testing at various temperatures. Deformation substructures and mechanisms have been systemically revealed from micrometer to atomic scales by using advanced scanning electron and scanning transmission electron microscopes. Results show that deformation mode of the alloy strongly depends on the temperature due to competitive responses of the gamma and gamma' phases under mechanical loading and their original stress statuses. At temperatures from ambient to 750 degrees C, plasticity is governed by dislocation shearing in both phases, where slip modes of gamma are < 110 >{111} and those of gamma' are < 112 >{111}, < 110 >{111} and < 110 > {001}. At moderate temperatures (850 degrees C <= T <= 900 degrees C), plasticity mainly involves microscopically uniform deformation of both phases. The matrix deforms first so that channels parallel to tensile direction are narrowed due to the Poisson's effect, after that deformation of gamma' follows. The active slip modes are < 110 > {111} for gamma, < 112 >{111}, < 110 >{111}, < 110 >{001}, and < 001 >{001} for gamma'. At temperature higher than 1000 degrees C, plastic strain is also derived from deformation of both phases, but deformation of the matrix plays critical roles, due to relatively weak strength of this phase. The operative slip modes are < 110 > {111} for gamma, but mainly < 110 >{001} and < 001 >{001} for gamma'. Our results clearly provide a comprehensive and multiscale (from micrometer to atomic) understanding on the deformation mechanism of Ni-based superalloys, which can be critically beneficial and offer mechanistic guidelines to design new/next generation superalloys. (c) 2021 Elsevier Ltd. All rights reserved.

Deformation Micro-Twinning Arising at High Temperatures in a Ni-Co-based Superalloy

A Molecular Dynamics Study on Mechanical Performance and Deformation Mechanisms in Nanotwinned NiCo-based Alloys with Nano-Precipitates under High Temperatures

Refining Micron-Sized Grains to Nanoscale in Ni-Co Based Superalloy by Quasistatical Compressive Deformation at High Temperature

Temperature Effects on Deformation Substructures and Mechanisms of a Ni-based Single Crystal Superalloy

Temperature Effects on the Deformation Mechanisms in a Ni-Co-Based Superalloys

Deformation twinning induced by micropores in TMS-75 superalloy

Temperature effects on the transition from Lomer-Cottrell locks to deformation twinning in a Ni-Co-based superalloy

Failure-mode dependence on the formation of deformation twinning in the fourth-generation single crystal Ni-based superalloy at high temperatures

Effect of γ' phase and microtwins on the microstructural evolution and mechanical properties of a novel Ni–Co base superalloy

Microtwinning in the nickel-based superalloy CM247LC during compression tests

Effects of Nano-Twinning on the Deformation and Mechanical Behaviours of TiAl Alloys with Distinct Microstructure at Elevated Loading Temperatures

Deformation Twinning Behaviors of the Low Stacking Fault Energy High-Entropy Alloy: an In-Situ TEM Study

The Temperature Dependence of High-Temperature Strength and Deformation Mechanism in a Single Crystal CoNi-base Superalloy

Temperature dependence on tensile deformation mechanisms in a novel Nickel-based single crystal superalloy

Stress-induced Crystallographic and Microstructural Evolution for Hierarchically Twinned Martensite in Single- and Dual-Phase Ni-Mn-Ga Alloys

Tailoring the Deformation Mechanisms in a Ni-Co-based Superalloy by Controlling Γ′ Precipitate Size

In Situ Study of the Microstructural Evolution of Nickel-Based Superalloys with High Proportional Twin Boundaries Obtained by High-Temperature Annealing

Plastic Deformation Behaviors and Mechanical Properties of Advanced Single Crystalline CoNi-base Superalloys

High-temperature tensile properties and strengthening mechanism of cryo-rolled MP159 superalloy strengthened by deformation nano-twins

Tensile Deformation Mechanisms at Various Temperatures in a New Directionally Solidified Ni-base Superalloy

Evolutionary Mechanisms in the Plastic Deformation of Γ'-Ni3(al, Ti)-strengthened Additively Manufactured Nickel-Based 939 Superalloys at Intermediate Temperatures