Abstract:III-Nitride metal-oxide-semiconductor field effect transistors (MOSFETs) have great potential for next generation energy-efficient power switching. Due to the fail-safe consideration, the enhancement-mode (E-mode) operation is highly desirable for GaN MOSFETs in power electronics. Furthermore, in high frequency switching applications, devices with high V TH (e.g. V TH>6 V) and large gate swing (e.g. >10 V) are required to prevent them from faulty turn-on due to the gate driver failure or electromagnetic interference. Many approaches have been demonstrated in pushing the V TH more positive [1], [2]. However, achieving high V TH and good performance simultaneously remains a major challenge due to positive interface fixed charges [3], [4]. In this paper, the presence of positive interface fixed charges (Q it~1.44×1013 cm-2) at the ALD-Al2O3/GaN interface was found in the fully recessed Al2O3/GaN MOSFETs. The origin of the interface charges is proposed to be the Ga-O bond and metal Ga dangling bond (DB) at the Al2O3/GaN interface generated in the gate recessing process and Al2O3 deposition, respectively. An efficient approach to engineer the interface positive fixed charges was demonstrated by post-dielectric annealing (PDA) in N2, resulting in a reduction of Q it from 1.44×1013 to 3×1012 cm-2. The reduction of Q it leads to a significant positive shift in V TH and an increase of electron mobility that enabling the E-mode operation of Al2O3/GaN MOSFETs with a uniquely high V TH of +7.6 V and drive current as high as 355 mA/mm. The interface charge engineering method demonstrated in this work is promising to fabricate E-mode GaN devices with uniquely higher V TH and low on-resistance. References 1. Y.-H. Wang, et al., IEEE Electron Device Lett., 36, (2015). 2. Z. Tang, et al., IEEE Electron Device Lett., 34, (2013). 3. M. Esposto, et al., Appl. Phys. Lett., 99, (2011). 4. S. Ganguly, et al., Appl. Phys. Lett., 99, (2011). Figure 1

Threshold Voltage Modulation Engineering Using P‐type CuO and NiO for the AlGaN/GaN Enhancement‐Mode Fin‐MOS‐HEMTs on the Si Substrates

(Invited) Threshold Voltage Modulation by Interface Charge Engineering for High Performance Enhancement-Mode Al2O3/GaN Power Mosfets

Simulation study on electrical properties of p-GaN gate normally-off HEMT devices affected by Al mole fraction in AlGaN barrier layer

5.3A/400V Normally-off AlGaN/GaN-on-Si MOS-HEMT with High Threshold Voltage and Large Gate Swing

Low Threshold Voltage Shift in AlGaN/GaN MIS-HEMTs on Si Substrate Using SiNx/SiON As Composite Gate Dielectric

A Fin-p-GaN HEMT for High Threshold Voltage with Enhanced Stability.

Simulation and analysis of enhancement-mode AlGaN/GaN HEMT with P-I-N junction gate

Wide-range-adjusted threshold voltages for E-mode AlGaN/GaN HEMT with a p-SnO cap gate

Threshold Voltage Modulation Mechanism of AlGaN/GaN Metal-Insulator-semiconductor High-Electron Mobility Transistors with Fluorinated Al2O3 As Gate Dielectrics

Over 1200 V Normally-OFF P-Nio Gated AlGaN/GaN HEMTs on Si with a Small Threshold Voltage Shift

Investigation of Electrical Property and Thermal Stability in Enhancement-Mode InxAl1–xN/AlN/GaN MOS-HEMTs Fabricated by Using NiOx Gate and Fluorine Treatment

Enhanced Device Performance of AlGaN/GaN HEMTs Using Thermal Oxidation of Electron-Beam Deposited Aluminum for Gate Oxide

Threshold voltage control by gate oxide thickness in fluorinated GaN metal-oxide-semiconductor high-electron-mobility transistors

High-Efficiency Millimeter-Wave Enhancement-Mode Ultrathin-Barrier AlGaN/GaN Fin-HEMT for Low-Voltage Terminal Applications

Channel Engineering of Normally-OFF AlGaN/GaN MOS-HEMTs by Atomic Layer Etching and High- $\kappa$ Dielectric

Threshold Voltage Modulation and Gate Leakage Suppression of Enhancement-Mode GaN HEMT by Metal/Insulator/p-GaN Gate Structure

Simulation Study of the Use of AlGaN/GaN Ultra-Thin-Barrier HEMTs with Hybrid Gates for Achieving a Wide Threshold Voltage Modulation Range

A novel enhancement-mode GaN vertical MOSFET with double hetero-junction for threshold voltage modulation

Threshold Voltage Modulation by Interface Charge Engineering for High Performance Normally-off GaN MOSFETs with High Faulty Turn-on Immunity

High Voltage Normally-Off p-GaN Gate HEMT with the Compatible High Threshold and Drain Current

7.6 V Threshold Voltage High-Performance Normally-Off Al2o3/Gan Mosfet Achieved by Interface Charge Engineering