Abstract:The photovoltaic properties of the polycrystalline silicon depend on the crystallinity and the purity of the material. The thermal plasma process gives us an alternative method of silicon preparation since it is possible to produce an ultrahigh purity with simultaneously a passivation of crystalline defects and active impurities. We demonstrate the efficiency of the plasma purification process and particularly the influence of the atomic hydrogen in an argon thermal plasma on the photovoltaic properties of silicon. The results of the diffusion lengths measured by the photoelectrochemical method show that locally it rises up to 200 μm. We correlate these photovoltaic measurements with the properties of the crystal (defects and purity) by means of measurements by Fourier transform infrared spectroscopy (FTIR) at low temperature (6 K), four probes resistivity technique, scanning electronic microscopy, inductively coupled plasma (ICP), and neutronic activation analyses. We show that the increase of the purity explains the high me asured diffusion lengths. Nevertheless, the thermal conditions of the crystallization of the silicon, due to the specificity of the plasma, lead to defects such as dislocations for which density is particularly high (>10 6 dis/cm 2 ). The results show that chemical reactions between the atomic hydrogen of the plasma and the oxygen of the silicon occur. They decrease the oxygen content in silicon from 3 × 10 17 at./cm 3 down to 2 × 10 16 at./cm 3 , while the residual hydrogen in silicon is close to 2 × 10 15 at./cm 3 . This passivates the dangling bonds of ultrapure silicon with a high thermal stability up to 1000 K. The objective of this paper is to demonstrate that the hydrogen in the plasma modifies the electronic properties of the material to achieve a very good photocurrent even though the dislocation density of the silicon is very high.

Polysilicon Prepared from SiCl4by Atmospheric-Pressure Non-Thermal Plasma

A parametric study of non-thermal plasma synthesis of silicon nanoparticles from a chlorinated precursor

Floating Low-Temperature Radio-Frequency Plasma Oxidation of Polycrystalline Silicon-Germanium

Non-equilibrium,Atmospheric-pressure Plasma Jet for Depositing Silicon Oxide Films

Manufacture of Granular Polysilicon from Trichlorosilane in a Fluidized-Bed Reactor

Thermodynamic Analysis of Manufacturing Polysilicon from SiHCl3, SiCl4 and H2

In-Flight Dry Etching of Plasma-Synthesized Silicon Nanocrystals

Doped Silicon Nanocrystals From Organic Dopant Precursor By A Sicl4-Based High Frequency Nonthermal Plasma

Facile Synthesis of Silicon Nanospheres and Nanosheets Using DC Thermal Plasma

Progress in Preparation Technology of Polysilicon

Polysilicon gate etching in high density plasmas. V. Comparison between quantitative chemical analysis of photoresist and oxide masked polysilicon gates etched in HBr/Cl2/O2 plasmas

Simple Synthesis of Ultrafine Amorphous Silicon Carbide Nanoparticles by Atmospheric Plasmas

High-Throughput Low Frequency Reactor for Non-Thermal Plasma Synthesis of Amorphous Silicon Nanoparticles

Preparation and Photoluminescence of Nanocrystalline Si-Rich Silicon Oxide Films by Pecvd

Recycling of SiCl4 in the Manufacture of Granular Polysilicon in a Fluidized Bed Reactor

Air-stable full-visible-spectrum emission from silicon nanocrystals synthesized by an all-gas-phase plasma approach.

Preparation of High Quality Polycrystalline Silicon Thin Films by Aluminum-Induced Crystallization

Growth of Poly-Crystalline Si Films on Flexible Substrate by Hot Wire Chemical Vapor Deposition

Low-Temperature Atmospheric-Pressure Plasma-Enhanced Chemical Deposition of Silicon Dioxide Films from Tetraethoxysilane

Low‐temperature atmospheric pressure plasma conversion of polydimethylsiloxane and polysilazane precursor layers to oxide thin films

Photovoltaic silicon produced by thermal plasma: Influence of atomic hydrogen on oxygen elimination and passivation of the crystal defects