Abstract:PurposeThe purpose of this paper is to investigate, experimentally and numerically, the pressure pulse characteristics and unsteady flow behavior in a Francis turbine runner for moderate flow heads. The pressure pulses in the runner blade passage were predicted numerically for both moderate and high heads. The calculations were used to partition the turbine operating regions and to clarify the various for the unsteady flow behavior, especially the blade channel vortex in the runner.Design/methodology/approachExperimental and numerical analyses of pressure pulse characteristics at moderate flow heads in a Francis turbine runner were then extended to high heads through numerical modeling with 3D unsteady numerical simulations performed for a number of operating conditions. The unsteady Reynolds‐averaged Navier‐Stokes equations with the k‐ω‐based shear stress transport turbulence model were used to model the unsteady flow within the entire flow passage of a Francis turbine.FindingsThe dominate frequency of the predicted pressure pulses at runner inlet agree with the experimental results in the head cover at moderate flow heads. The influence of the blade passing frequency causes the simulated peak‐to‐peak amplitudes in the runner inlet to be larger than in the head cover. The measured and predicted pressure pulses at different positions along the runner are comparable. At the most unstable operating condition of 0.5a0 guide vane opening, the pressure pulses in the runner blade passage are due to the blade channel vortex and the rotor‐stator interference. The predictions show that the frequency of the blade channel vortex is relatively low and it changes with the operating conditions.Originality/valueThe paper describes a study which experimentally and numerically investigated the pressure pulses characteristics in a Francis turbine runner at moderate flow heads. The pulse characteristics and unsteady flow behavior due to the blade channel vortex in the runner at high heads were investigated numerically, with the turbine operating regions then partitioned to identify safe operating regions.

Numerical Study On Three Dimensional Unsteady Flow Of A High Pressure Gas Turbine Stage

NUMERICAL INVESTIGATION OF STATOR CLOCKING EFFECTS ON THE DOWNSTREAM STATOR IN A 1.5-STAGE AXIAL TURBINE

Investigation of Unsteady Aerodynamic Excitation on Rotor Blade of Variable Geometry Turbine

Unsteady 3D-Numerical Investigation of the Influence of the Blading Design on the Stator-Rotor Interaction in a 2-Stage Turbine

Numerical Investigation Of Pressure Fluctuation And Rotor-Stator Interaction In A Multistage Centrifugal Pump

High-fidelity simulations of a high-pressure turbine stage: effects of Reynolds number and inlet turbulence

High-Fidelity Simulation Study of the Unsteady Flow Effects on High-Pressure Turbine Blade Performance

Generation and distribution of turbulence-induced forces on a propeller

Numerical Analysis of Blade Channel Vortex in Francis Turbine at Part Load of Middle-Low Head

Numerical Analysis of Unsteady Flow under High‐head Operating Conditions in Francis Turbine

Experimental and Numerical Analysis of Pressure Pulses Characteristics in A Francis Turbine with Partial Load

Numerical Simulation on Unsteady Flow Mechanism of a 1.5-Stage Axial Transonic Compressor

Study on Pressure Pulsation and Force Characteristics of Kaplan Turbine

Calculation of Pressure Pulsations in the Flow Part of the First Stage of an Axial Turbine in the Rotor-Stator Interaction Zone

Study of wake characteristics of a horizontal-axis wind turbine within two-phase flow

Numerical Analyses of Pressure Fluctuations Induced by Interblade Vortices in a Model Francis Turbine

Blade Excitation Related Flow Behavior Analysis on the Turbocharger’s Centrifugal Compressor with Volute and Casing Treatment

Experimental and Numerical Analysis of Blade Channel Vortices in A Francis Turbine Runner

THREE DIMENSIONAL VISCOUS FLOW NUMERICAL ANALYSIS OF STALL FLUTTER IN STEAM TURBINE BLADES

A Study and Optimization of the Unsteady Flow Characteristics in the Last Stage Impeller of a Small-Scale Multi-Stage Hydraulic Turbine

Numerical Simulation of Pressure Fluctuation in Kaplan Turbine