Abstract:Prediction and optimisation of non-cavitating marine propeller noise at low frequency are important for design of submarine propellers that are required to operate in the non-cavitating condition. The low-frequency discrete- and broadband-spectrum forces of propellers have different generation mechanisms, and thus have not previously been studied within a unified framework. In this work, the strip method is applied to simultaneously predict and optimise these two forces. First, the panel method is applied to predict the discrete-spectrum forces of different strips in the time domain. Then, the unsteady force of the whole propeller is obtained as the linear superposition of the shifted unsteady forces of all the strips, according to a skew distribution. The strip method is then used to numerically solve an integral equation for the broadband-spectrum force, derived via the spectral method. On the basis of experimental results, the predictions of low-frequency discrete- and broadband-spectrum forces are verified to have high accuracies. An analysis of the effect of propeller skew on the unsteady forces of different strips, and the effect of strip-cutting strategy on the broadband-spectrum force, is also performed. It is found that the skew of a strip is approximately equal to the angle of the circumferential phase shift of the unsteady force of that strip, and that the strip-cutting method has an insignificant effect on the predicted broadband-spectrum force. The optimisation of propeller performance under several constraints is then considered, with the particular objectives of maximising the propulsion efficiency and minimising the low-frequency discrete- and broadband-spectrum forces. The circumferential phase-shift effect of the skew allows the optimisation model to be decoupled into two steps. The discrete-spectrum force of the whole propeller can thus be computed using linear superposition rather than a hydrodynamic calculation, which significantly improves the computational efficiency. The effectiveness of the optimisation is verified by two optimization cases. For HSP, the propulsion efficiency is increased by 2.5%, the broadband-spectrum noise is reduced by approximately 0.6 dB, and the first- and second-order values of discrete-spectrum thrust are decreased by 9% and 27%, respectively. Similarly, for E1619, the first- and second-order values of the discrete-spectrum thrust are reduced by 13% and 18%, respectively.

Generation and distribution of turbulence-induced forces on a propeller

Unsteady Responses and Correlation Characteristics of Propeller Blades under Turbulence Excitation

Numerical investigation of parameters influencing the turbulence-ingesting noise of a ten-bladed propeller

Propeller wake instabilities under turbulent-inflow conditions

The study on the broadband thrust spectrum of propeller in anisotropic and inhomogeneous turbulence

Research on Formation Mechanism and Suppression Method of Surface Force Caused by Pump Jet Propeller

Experimental Study on Synchronous Observation of Propeller Cavitation and Induced Fluctuation Pressure

Experimental Investigation of Propeller Blade Back Cavitation Induced Pressure Pulses by Synchronous Observation

Numerical study of the hydrodynamic performances of surface piercing propeller

Unsteady Numerical Simulation of Cavitating Turbulent Flow Around A Highly Skewed Model Marine Propeller

Numerical Analysis of Cavitation Evolution and Excited Pressure Fluctuation Around a Propeller in Non-Uniform Wake

Numerical study of rotor unsteady forces and noise due to ingestion of grid-generated turbulence

Numerical study on unsteady propeller exciting characteristics considering shafting whirling vibration effect

Suppression Method for Exciting Force of Pump Jet Propellers Based on Sinusoidal Unevenly Spaced Rotor Blades

Noise of a shrouded propeller due to ingestion of grid-generated turbulence

Prediction and Optimisation of Low-Frequency Discrete- and Broadband-Spectrum Marine Propeller Forces

Numerical Study of Cavitating Turbulent Flow Around Propellers: Relationship of Cavity Volume Evolution and Pressure Fluctuation

Experimental study of the turbulence ingestion noise of rotor blades

Numerical study on the hydrodynamic performance and wake dynamics of propulsive wing propulsors with different cross-flow fans

Numerical Investigation of Unsteady Cavitating Turbulent Flow Around A Full Scale Marine Propeller

Effects of the stator prewhirl angle on the unsteady force under uniform and turbulent inflow for a pump-jet propulsor: a numerical study