Abstract:Unsteady cavitating turbulent flow simulations need to be responsible for both cavitation and turbulence modeling issues. The Partially-Averaged Navier–Stokes (PANS) computational model developed from the RANS method and the k–ε turbulence model are used to model turbulent cavitating flow with a mass transfer cavitation model in the present paper. An objective of this study is to pursue more accurate estimates of unsteady cavitating flows with large-scale fluctuations at a reasonable cost. Firstly, the unsteady cavitating flow simulations over a NACA66-mod hydrofoil are performed using the PANS method with various values of the resolution control parameters (fk=1∼0.2, fε=1) to evaluate the numerical methods based on experimental data. The comparison with the experiments show that the numerical analysis with a fk=0.2 can predict the cavity evolution and shedding frequency fairly well. Then, cavitating flow around a marine propeller in non-uniform wake was simulated by PANS method. The calculations show that large cavity volume pulsation as the blade passes through the wake region is resolved better by the PANS method with fk=0.2 than by the RANS method with the k–ε or k–ω SST turbulence models. This can be contributed to the fact that a smaller fk give larger cavity volume pulsations leading to increased cavity volume accelerations and larger pressure fluctuations above the propeller, while a larger fk overestimates the turbulent viscosity along the rear part of the cavity. Finally, it is confirmed from the simulation by the PANS method with fk=0.2 that the whole process of cavitating flow evolution around the propeller in non-uniform wake can be very well reproduced including cavitation inception, sheet cavitation and tip vortex cavitation observed experimentally.

Numerical Study of Cavitating Turbulent Flow Around Propellers: Relationship of Cavity Volume Evolution and Pressure Fluctuation

Unsteady Numerical Simulation of Cavitating Turbulent Flow Around A Highly Skewed Model Marine Propeller

Unsteady cavitation characteristics and alleviation of pressure fluctuations around marine propellers with different skew angles

Numerical Analysis of Cavitation Evolution and Excited Pressure Fluctuation Around a Propeller in Non-Uniform Wake

Numerical Investigation of Unsteady Cavitating Turbulent Flow Around A Full Scale Marine Propeller

Numerical study of the hydrodynamic performances of surface piercing propeller

Numerical Modelling of Unsteady Cavitation and Induced Noise Around a Marine Propeller

Partially-Averaged Navier-Stokes method with modified k-ε model for cavitating flow around a marine propeller in a non-uniform wake

Experimental Study on Synchronous Observation of Propeller Cavitation and Induced Fluctuation Pressure

Numerical Prediction of Cavitation Fatigue Life and Hydrodynamic Performance of Marine Propellers

Experimental Investigation of Propeller Blade Back Cavitation Induced Pressure Pulses by Synchronous Observation

Unsteady Responses and Correlation Characteristics of Propeller Blades under Turbulence Excitation

Modeling study of wake cavitation characteristics of DTMB propeller based on numerical computation

Numerical Simulation of Cavitation Characteristics for Pump-Jet Propeller

Numerical investigation of three-dimensional cavitation evolution and excited pressure fluctuations around a twisted hydrofoil

Numerical Prediction of Cavitation Performance of Controllable Pitch Propellers with Different Pitch Adjustment Velocities

Numerical Study on the Unsteady Characteristics of the Propeller Cavitation in Uniform and Nonuniform Wake Flows

Experimental and Numerical Investigation of Blade Geometry Effect on Propeller Cavitation and Noise

Numerical simulation of the cavitating noise of contra-rotating propellers based on detached eddy simulation and the Ffowcs Williams–Hawkings acoustics equation

Large Eddy Simulation of Unsteady Cavitating Flow Around A Highly Skewed Propeller in Nonuniform Wake

Numerical Simulation of Unsteady Cavitating Flows of Pumpjet Propulsor