Abstract:Unsteady cavitating turbulent flow simulations need to be responsible for both cavitation and turbulence modeling issues. The Partially-Averaged Navier–Stokes (PANS) computational model developed from the RANS method and the k–ε turbulence model are used to model turbulent cavitating flow with a mass transfer cavitation model in the present paper. An objective of this study is to pursue more accurate estimates of unsteady cavitating flows with large-scale fluctuations at a reasonable cost. Firstly, the unsteady cavitating flow simulations over a NACA66-mod hydrofoil are performed using the PANS method with various values of the resolution control parameters (fk=1∼0.2, fε=1) to evaluate the numerical methods based on experimental data. The comparison with the experiments show that the numerical analysis with a fk=0.2 can predict the cavity evolution and shedding frequency fairly well. Then, cavitating flow around a marine propeller in non-uniform wake was simulated by PANS method. The calculations show that large cavity volume pulsation as the blade passes through the wake region is resolved better by the PANS method with fk=0.2 than by the RANS method with the k–ε or k–ω SST turbulence models. This can be contributed to the fact that a smaller fk give larger cavity volume pulsations leading to increased cavity volume accelerations and larger pressure fluctuations above the propeller, while a larger fk overestimates the turbulent viscosity along the rear part of the cavity. Finally, it is confirmed from the simulation by the PANS method with fk=0.2 that the whole process of cavitating flow evolution around the propeller in non-uniform wake can be very well reproduced including cavitation inception, sheet cavitation and tip vortex cavitation observed experimentally.

Three-dimensional flows in the wake of a non-cavitating and cavitating marine propeller

Numerical Study of Cavitating Turbulent Flow Around Propellers: Relationship of Cavity Volume Evolution and Pressure Fluctuation

Dynamics of cavitating tip vortex

Numerical Investigation of Unsteady Cavitating Turbulent Flow Around A Full Scale Marine Propeller

Tomographic PIV Investigation on Near-Wake Structures of a Hemisphere Immersed in a Laminar Boundary Layer

Tomographic Particle Image Velocimetry Investigation on Flow Characteristics and Pressure–velocity Relation of a Near-Field Tip Vortex

High-speed visualization of cavitation evolution around a marine propeller

Flow field measurements around a marine propeller tip and vortex identification procedures

Numerical Analysis of Cavitation Evolution and Excited Pressure Fluctuation Around a Propeller in Non-Uniform Wake

Experimental Investigation of Propeller Blade Back Cavitation Induced Pressure Pulses by Synchronous Observation

Experimental Study on Pressure-Velocity Relation of Near-Field Tip Vortex Using Tomographic PIV

Unsteady Numerical Simulation of Cavitating Turbulent Flow Around A Highly Skewed Model Marine Propeller

Modeling study of wake cavitation characteristics of DTMB propeller based on numerical computation

Partially-Averaged Navier-Stokes method with modified k-ε model for cavitating flow around a marine propeller in a non-uniform wake

Numerical Modelling of Unsteady Cavitation and Induced Noise Around a Marine Propeller

Flow and Cavity Measurements in a Super-Cavitating Propeller

Numerical study of the hydrodynamic performances of surface piercing propeller

A numerical formulation for cavitating flows around marine propellers based on variational multiscale method

Modeling of Hydroacoustic Noise from Marine Propellers with Tip Vortex Cavitation

The Motion of Small Bubble in the Ideal Vortex Flow

Numerical Study on the Unsteady Characteristics of the Propeller Cavitation in Uniform and Nonuniform Wake Flows