Abstract:{ 10 1 over bar 2 } twins were introduced into the magnesium (Mg) plate AZ31 via pre-rolling along its transverse direction. The plates, both with and without the pre-induced { 10 1 over bar 2 } twins, were subjected to uniaxial tension along different directions. Using crystal plasticity modeling, we found that the strengthening effect of the pre-induced { 10 1 over bar 2 } twins on the macroscopic flow stress primarily arised from the increased slip resistance caused by the boundaries, rather than the orientation hardening due to the twinning reorientation (although the latter did make its contribution in some specific loading directions). Besides, the pre-existing { 10 1 over bar 2 } twins were found, by both experiments and simulation, to promote the activity of prismatic (a � and pyramidal < c + a > in the parent matrix of the material. Further analysis showed that the enhanced non-basal slip activity is related to the { 10 1 over bar 2 } twin boundaries' low micro Hall-Petch slope ratios of non-basal slips to basal slip. With the critical resolved shear stress (CRSS) obtained from crystal plasticity modeling and the orientation data from EBSD, a probability-based slip transfer model was proposed. The model predicts higher slip transfer probabilities and thus lower strain concentration tendencies at { 10 1 over bar 2 } twin boundaries than that at grain boundaries, which agrees with the experimental observation that the strain localization was primarily associated with the latter. The present findings are helpful scientifically, in deepening our understanding of how the pre-induced { 10 1 over bar 2 } twins affect the strength and slip activity of Mg alloys, and technologically, in guiding the design of the pre-strain protocol of Mg alloys. & COPY; 2021 Chongqing University. Publishing services provided by Elsevier B.V. on behalf of KeAi Communications Co. Ltd. This is an open access article under the CC BY-NC-ND license ( http://creativecommons.org/licenses/by-nc-nd/4.0/) Peer review under responsibility of Chongqing University

Origin Of Twin-Like {33(3)Over-Bar4} Tilt Boundary And Associated Solute Segregation In A High Strain Rate Deformed Mg-Y Alloy

Origin of Twin-Like {336¯4} Tilt Boundary and Associated Solute Segregation in a High Strain Rate Deformed Mg-Y Alloy

Origin of twin-like { 33 6 ̄ 4 } tilt boundary and associated solute segregation in a high strain rate deformed Mg-Y alloy

Crystallographic Features of 11¯00 Axis Tilt Boundaries in a High Strain Rate Deformed Mg 9Y Alloy

Crystallographic features of < 1 1 ̄ 00 > axis tilt boundaries in a high strain rate deformed Mg 9Y alloy

Unravelling the Local Ring-Like Atomic Pattern of Twin Boundary in an Mg-Zn-Y Alloy

Origin of profuse {11(2)over-bar1} deformation twins in Mg-Gd alloys

Isometric Tilt Grain Boundaries and Solute Segregation in a Deformed Mg-Zn-Ca Alloy

The Dislocation-Twin Interaction and Evolution of Twin Boundary in AZ31 Mg Alloy

Tilt Boundaries and Associated Solute Segregation in a Mg–Gd Alloy

The Effect of Basal Dislocation on 112¯1 Twin Boundary Evolution in a Mg-Gd-Y-Zr Alloy

Identification and Analysis of Anomalous {101‾2} Twins in an Extruded Mg-2wt%Y Alloy Sheet During Uniaxial Tensile Loading

Solute Segregation and Pinning Effect on Lateral Twin Boundary in Magnesium

{ 10 1 ̄ 2 } twin–twin intersection-induced lattice rotation and dynamic recrystallization in Mg–6Al–3Sn–2Zn alloy

Detwining In Mg Alloy With A High Density Of Twin Boundaries

Twin-twin Geometric Structure Effect on the Twinning Behavior of an Mg-4Y-3Nd-2Sm-0.5Zr Alloy Traced by Quasi-in-situ EBSD

Evolution of deformation mechanisms and their orientation dependence in fine-grained Mg-3Gd during tension

{10(1)Over-Bar2} - {10(1)Over-Bar2} Double Tensile Twinning In A Mg-3al-1zn Alloy Sheet During Cyclic Deformation

Ductility Improvement by Twinning and Twin–slip Interaction in a Mg-Y Alloy

On the Strengthening and Slip Activity of Mg-3Al-1Zn Alloy with Pre-Induced { 10 1 over Bar 2 } Twins

Computational Study of <11¯00> Symmetric Tilt Grain Boundaries in Mg and Ti