Abstract:Concentrated saline solutions are inevitably used as coolants in the industry heat exchangers. From the aspect of simulation prediction, the closure models for RPI model, including the models of bubble departure diameter (Dw), departure frequency (f) and active nucleation site density (Nw), are of great importance for the overall success of heat transfer calculation. However, the applicability of the existing closure models for the nucleate flow boiling of saline solutions is yet to be answered. In this paper, the experiments of subcooled flow boiling of the NaCl solutions with concentration range of 0%–6% were conducted. The experimental data of the three bubble parameters, Dw, f and Nw, were obtained under different operating conditions, making up for the shortage of the bubble parameter data of saline solution in literature. The impacts of key influencing parameters for each of the three bubble parameters were discussed. For model development, the prediction performance of several existing representative Dw, f and Nw models on saline solution were studied. The results indicate that the available models for Dw, f and Nw show rather large deviations for saline solutions. Therefore, new models for Dw, f and Nw were developed according to the correlation method and the influencing parameter analyses. The parameters and dimensionless groups, which can be used to characterize the variations of Nw, Dw and f, were determined. The dimensionless parameters including Boiling number (Bo), density ratio (ρ⁎), dimensionless surface tension, Prandtl number and a suggested dimensionless temperature (ΛT), can be used to characterize the variation of Dw. And the dimensionless groups of Bo, ρ⁎, ΛT, and the non-dimensional bubble departure diameter, can be used to correlating with the non-dimensional departure frequency. As for Nw, the wall superheat and solution concentration are the most critical factors for model correlating. The new correlations for predicting the Dw, f and Nw during subcooled flow boiling in both the pure water and saline solutions were built and validated.

HEAT TRANSFER CHARACTERISTICS AND BUBBLE BEHAVIORS DURING NUCLEATE FLOW BOILING FOR SODIUM CHLORIDE SOLUTION

Experimental Study of Heat Transfer and Bubble Behaviors of NaCl Solutions During Nucleate Flow Boiling

Experimental and Numerical Study of Nucleate Pool Boiling Heat Transfer and Bubble Dynamics in Saline Solution

Wall Heat Flux Partitioning During Subcooled Flow Boiling of NaCl Solutions and Pure Water

Impacts of Salt Concentration on Nucleate Pool Boiling of NaCl Solution

Experimental Investigation on Heat Transfer Characteristics in Circulatory Flash Vaporization of Aqueous NaCl Solution

Bubble Growth in NaCl Solution: Influence of Superheat Temperature and Solution Concentration

Development of Bubble Dynamic Parameter Models in Subcooled Flow Boiling of Saline Solution

Experimental Investigation on the Heat Transfer Characteristics of Molten Salt to Subcooled Boiling Water

Influence of Hydrodynamic Interactions among Multiple Bubbles on Convective Heat Transfer in Nucleate Boiling

Experimental Investigation of Heat Transfer Performance of Solar Salt and Subcritical Water/Steam

Experimental Investigation on the Shell-Side Heat Transfer Performance of Molten Salt Steam Generator

Visualization and quantitative study on film boiling heat transfer of a salt droplet on the hydrophobic substrate

Bubble behaviors during subcooled pool boiling in water and nonionic surfactant aqueous solution

Flow boiling heat transfer and pressure fluctuation characteristics in a divergent channel with inclined downward-facing heater

EXPERIMENTAL STUDY ON THE CRITICAL HEAT FLUX OF NANOFLUID FLOW BOILING UNDER DIFFERENT CONDITIONS

Visual Experimental Study on Bubble Characteristics Near the Heating Wall in Subcooled Flow Boiling

A Simulation of Bubble Growth on Heating Surface in Subcooled Boiling Water Based on the Heat Flows Derived by Experiment

Experimental study on subcooled pool boiling heat transfer of sodium dodecyl sulfate surfactant solution

Synergistic Effects of Hydrophilic-Hydrophobic Porous Structures for Enhancing Nucleate Pool Boiling Heat Transfer

Experimental Study on Heat Transfer Characteristics of LN2 Saturated Flow Boiling in a Horizontal Corrugated Tube