Abstract:Unsteady cavitating turbulent flow simulations need to be responsible for both cavitation and turbulence modeling issues. The Partially-Averaged Navier–Stokes (PANS) computational model developed from the RANS method and the k–ε turbulence model are used to model turbulent cavitating flow with a mass transfer cavitation model in the present paper. An objective of this study is to pursue more accurate estimates of unsteady cavitating flows with large-scale fluctuations at a reasonable cost. Firstly, the unsteady cavitating flow simulations over a NACA66-mod hydrofoil are performed using the PANS method with various values of the resolution control parameters (fk=1∼0.2, fε=1) to evaluate the numerical methods based on experimental data. The comparison with the experiments show that the numerical analysis with a fk=0.2 can predict the cavity evolution and shedding frequency fairly well. Then, cavitating flow around a marine propeller in non-uniform wake was simulated by PANS method. The calculations show that large cavity volume pulsation as the blade passes through the wake region is resolved better by the PANS method with fk=0.2 than by the RANS method with the k–ε or k–ω SST turbulence models. This can be contributed to the fact that a smaller fk give larger cavity volume pulsations leading to increased cavity volume accelerations and larger pressure fluctuations above the propeller, while a larger fk overestimates the turbulent viscosity along the rear part of the cavity. Finally, it is confirmed from the simulation by the PANS method with fk=0.2 that the whole process of cavitating flow evolution around the propeller in non-uniform wake can be very well reproduced including cavitation inception, sheet cavitation and tip vortex cavitation observed experimentally.

Numerical analysis of contra-rotating propellers′unsteady hydrodynamic performance

Strength Evaluation of the Composite Propeller under Hydrodynamic Fluid Load

Numerical study of the hydrodynamic performances of surface piercing propeller

Numerical Study of Hydrodynamic Performance of A High Maneuverability Ocean Engineering Ship with Pod Propeller Design

Numerical Investigation of Influence of Rotor-Rotor Gap on Performances of Contra-Rotating Axial Flow Pump

Parameterized design method and verification of propeller single-passage domain

Numerical Simulation of Unsteady Flow Around Propeller Based on CFD Technology

Unsteady Responses and Correlation Characteristics of Propeller Blades under Turbulence Excitation

Spatial Fluctuating Pressure Calculation of Underwater Counter Rotating Propellers under Noncavitating Condition

Numerical study on transient four-quadrant hydrodynamic performance of cycloidal propellers

Numerical analysis on dynamic behaviors of coupled propeller-shafting system of underwater vehicles

Numerical simulation on the hydrodynamic performance of an azimuthing pushing podded propulsor in reverse flow and rotation

Numerical simulation to assess hydrodynamic performance of cycloidal propellers during maneuvering

Generation and distribution of turbulence-induced forces on a propeller

Research on the hydrodynamic performance of propellers under oblique flow conditions

Simulating Unsteady Aerodynamics of Helicopter Rotor with Panel/viscous Vortex Particle Method

Partially-Averaged Navier-Stokes method with modified k-ε model for cavitating flow around a marine propeller in a non-uniform wake

Numerical simulation of cavitation performance of podded propulsion under maneuvering condition

Modeling and the Control Strategy of the Coaxial Contra-Rotating Propeller System

Fluid-Solid Coupling Analysis of the Propeller and Optimization of Boss Cap Fin Parameters

Panel/full-span Free-Wake Coupled Method for Unsteady Aerodynamics of Helicopter Rotor Blade