Abstract:In order to achieve the ultra-clean emission standards, many power plants in China have completed the installation of low-low temperature flue gas system. However, during the operation of this system, many problems have emerged, such as the ash deposition problem in the heat exchanger and dry ESP (electrostatic precipitator). In this paper, the fixed adsorption system and entrained flow experimental system were built to study the ash deposition characteristics in low-low temperature flue gas system under different temperatures and particle sizes. The repose angle was measured to evaluate the flowability and adhesion capacity of ash particles. The results show that as the increase of adsorption time, the particle size increased gradually, and the agglomeration effect is attenuated after the particles have reached adsorption saturation. The time at which the ash particles began to agglomerate with each other was defined as the agglomeration threshold. As the adsorption temperature decreased, the particle size growth rate increased. The smaller the size of ash particles, the more significant the agglomeration effect. Large particles were easy to adsorb small particles, but the agglomeration effect between large particles was weak. In addition, in the initial stage of particle agglomeration, it was mainly included the adhesion between smaller particles and the adhesion of smaller particles on the surface of large particles. The followability of the ash particles was greatly reduced after the adsorption and agglomeration process. The repose angle of the ash particles increased as the temperature of the flue gas decreased. The smaller the particle size, the larger the repose angle changes, and the more pronounced the repose angle is influenced by the adsorption temperature. The flue gas temperature cannot be blindly dropped in pursuit of high sulfur oxide removal efficiency and dust removal efficiency.

Experimental Study on the Influencing Factors of Metastable Zone of FGD Wastewater in Coal-fired Power Plants

Streamer Plasma Induced Ammonia Flue Gas Desulfurization

Study on Spray Evaporation Treatment of Desulfurization Wastewater

Experimental study on factors affecting the ammonia-based WFGD process

The Technology of Coal-fired Flue Gas Dechlorination for Realizing Zero-discharge of Desulfurization Wastewater and Its Influences on Boiler

Study on the Effect of Wet Flue Gas Desulphurization (WFGD) Technology on Flue Gas Particle Emission from Power Plants

Experimental Study on Emission Characteristics of Particulate Matters from Wet Flue Gas Desulfurization System of a Coal-fired Power Plant

Study on characteristics of organic components in condensable particulate matter before and after wet flue gas desulfurization system of coal-fired power plants

Application and experimental investigation of compound additive enhanced wet flue gas desulfurization process

STUDY ON AFFECTING FACTORS UPON WATER CONSUMPTION IN WET FGD SYSTEM

Study on the Effects of Wet Flue Gas Desulfurization on Particulate Matter Emission from Industrial Coal-Fired Power Plants

Origin and solution of the“gypsum rain”problem of limestone-gypsum WFGD system

AN EXPERIMENTAL INVESTIGATION ON HUMIDIFIED ACTIVATION FLUE GAS DESULFURIZATION WITH HIGH CaO CONTENT FLY ASH

STUDY ON DESULFURIZATION CHARACTERISTIC IN CaO ACTIVATION REACTOR OF LIMESTONE INJECTION FGD SYSTEM --EXPERIMENTAL RESULTS AND DISCUSSION

Experimental Study on the Slagging of Power Station Incinerator

Operating experience of CFB semi-dry FGD with novel humidification technology in China

Research on wet flue gas desulfurization by waste

Analysis of Main Influencing Factors of the Wastewater Evaporation in Flue Duct

Influence of circulating medium temperature on water consumption of wet FGD

Experimental Study on Removal Effect of Wet Flue Gas Desulfurization System on Fine Particles from a Coal-fired Power Plant

An Experimental Study on Ash Deposition Problem of Low-Low Temperature Flue Gas System