Abstract:Fly-ash particles from the inlet and outlet of the wet flue gas desulphurization(WFGD) system in a 300 MW coal-fired power plant were sampled by an Andersen 8-stage impactor and the mass concentrations and size distributions of fly-ash particles in flue gas were obtained. The samplings were developed under 100% and 70% boiler loads. The microstructure, major and minor-element concentrations of particles were measured using field emission scanning electron microscopy/energy dispersive X-ray spectrometry(FESEM- EDS), X-ray fluorescence(XRF) and inductively coupled plasma - atomic emission spectrometry (ICP-AES), respectively. The results indicate that the mass size distribution of fly-ash particles in the inlet of the WFGD system is typically disturbed bimodally, the peaks are approximate at 1 and 3 μm. And the shape of particles is regular sphericity, the mass ratio of PM2.5 to PM10 is about 0.434. The total mass concentration is about 85 mg/m3. In the outlet of the WFGD system, the mass size distribution of fly-ash particles is also bimodal. The proportion of fine particles increased, the mass ratio of PM2.5 to PM10 is about 0.764. Some fine particles are conglutinated and formed irregular agglomerate. The total mass concentration is under 23 mg/m3, the removal efficiency of total particles is 74.5%. The size removal efficiency is decreased observably with the range of particle size decreasing. After the WFGD system, the element concentrations of S and Ca in fine particles are augmented, and the concentrations of Al, Ba, Fe, Mn and Si are decreased oppositely. Fine particles in the outlet of WFGD system consist of about 47.5% limestone and 7.9% gypsum particulate matters.

AN EXPERIMENTAL INVESTIGATION ON HUMIDIFIED ACTIVATION FLUE GAS DESULFURIZATION WITH HIGH CaO CONTENT FLY ASH

STUDY ON DESULFURIZATION CHARACTERISTIC IN CaO ACTIVATION REACTOR OF LIMESTONE INJECTION FGD SYSTEM --EXPERIMENTAL RESULTS AND DISCUSSION

Experimental Research on the CFB-FGD of Semi-Dry Process in Ambient Temperature in a Demo Plant

Experimental Study on Combustion Desulfurization of Sludge Coal Water Slurry

Experimental Study on Removal Effect of Wet Flue Gas Desulfurization System on Fine Particles from a Coal-fired Power Plant

Experimental Study on the Cfb-Fgd of Semi-Dry Process in A Demo Plant

Experimental Study of Semi-dry Flue Gas Desulfurization in Circulating Suspension Fluidized Bed

Application and experimental investigation of compound additive enhanced wet flue gas desulfurization process

Optimization of CaO Particle Preparation and Performance Tests in a Bench Scale Circulating Fluidized Bed Reactor

Operating experience of CFB semi-dry FGD with novel humidification technology in China

Hydration and Desulphurization of Fly Ash of Circulating Fluidized Bed Boiler

Investigation on Removal Effects and Condensation Characteristics of Condensable Particulate Matter: Field Test and Experimental Study.

Experimental study on influence of multi-stage humidification on semi-dry flue gas desulfurization

Experimental Investigation on Disposal of the Product from a Slurry Jet WFGD

Experimental Study on Emission Characteristics of Particulate Matters from Wet Flue Gas Desulfurization System of a Coal-fired Power Plant

Experimental Investigation of the Optimum Reaction Temperature of Flue Gas Desulfurization Reaction Involving CaO Particles

A STUDY ON INTER-RECIPROCITY OF DESULPHURIZATION AND DECHLORINATION DURING CO-FIRING OF COAL AND SAWDUST

Pilot Plant Study of Wet Slurry Jet Flue Gas Desulfurization

Experimental Study on the Preparation of Desulfurizer for Low Temperature Dry Desulfurization by Digesting CaO in Urea Solution

Recent Advances in Flue Gas Desulphurization in Coal-Fired Power Plant

Research on Properties of Ammonia-Bisulfite WFGD in Stone-Coal Fired Power Plant