Abstract:Vented methane deflagrations in a 1 m3 vessel were investigated.Double flame acceleration phenomena were observed.CFD software FLACS was validated against experimental data.The mechanisms of the external overpressure peaks were revealed.The location of the external explosion was determined.This paper experimentally investigated the effect of low vent burst pressure on the overpressure buildup and flame evolution during the vented methane-air deflagrations in a 1 m3 rectangular vessel. CFD software FLACS was assessed in simulation of vented methane-air explosions against the experiment. Experimental results demonstrate that four overpressure peaks of Popen, Pout, Pext and Pacc from the vent failure, flame venting, external explosion and acoustically enhanced combustion, respectively, were observed except for the free venting case, in which only two overpressure peaks of Pout and Pext were monitored. The flame behaviors corresponding to different overpressure peaks were monitored especially at Pacc, where an abrupt increase in flame luminosity was observed on the bottom of the vessel due to the combustion of pockets of flammable mixture. Popen and Pacc increase with the vent burst pressure while Pout and Pext are nearly independent of the vent burst pressure. Double flame accelerations were observed owing to the vent rupture and flame venting. The phenomena of Helmholtz oscillation and the bulk motion of flame bubble always appeared after the vent rupture. The predicted overpressure agrees reasonably well with the experimental data. The discrepancy of the predicted and measured maximum peak overpressures reduces with increasing vent burst pressure. The predicted maximum peak overpressure and external flame length are slightly larger than those in experiment, which would facilitate the safe design in explosion venting and offer a better guidance in risk assessment. The simulation results also show that two overpressure peaks were recorded resulting from the pressure wave propagating above the vessel and the external explosion, respectively.

Experimental Investigation into Deflagration of Small-Volume Combustible Vapour Clouds

NUMERICAL SIMULATION INTO DEFLAGRATION-FIELD OF COMBUSTIBLE VAPOUR CLOUD OPENING TO AIR

Studies of combustible cloud explosion with limited energy release

Research Progress of Unconfined Vapor Cloud Explosion

Research on Unconfined Vapour Explosion Based on the Little Agitation Theory

Characteristics of hydrogen-ammonia-air cloud explosion

Experimental Study on the Domino Effect in Explosions Caused by Vertically Distributed Methane/air Vapor Clouds

Experimental and numerical simulation study on the dispersion and explosion process of solid-liquid-air mixed three phase components

Experimental and numerical study on the effect of low vent burst pressure on vented methane-air deflagrations

Pressure waves generated by low steady speed flames traveling in combustible clouds

Experimental and theoretical evaluation of hydrogen cloud explosion with built-in obstacles

Flame behavior, shock wave, and instantaneous thermal field generated by unconfined vapor-liquid propylene oxide/air cloud detonation

Simulation of Pressure Waves During Deflagration Combustion of Clouds of Fuel-Air Mixtures

Investigation on unconfined hydrogen cloud explosion with external turbulence

Experimental study on the effects of ignition location and vent burst pressure on vented hydrogen-air deflagrations in a cubic vessel

Theoretical and Experimental Investigation of Explosion Characteristics of Hydrogen Explosion in a Closed Vessel

Combustion and flame characteristics of fuel cloud induced by flow ignition

Thermal and shock dynamics interactions in vapor-liquid two-phase detonation

Experimental study on external explosion for vented hydrogen deflagration in a rectangular tube with different vent coefficients

Experimental Study of External Flame Evolution and Temperature Characteristics after a Methane Explosion in a Rectangular Chamber

Investigation on vented ethanol-gasoline vapor explosion characteristics initiated via single and dual sparks