Abstract:Gas explosions are major disasters in coal mining. and they typically cause a large number of deaths, injuries and property losses. An appropriate understanding of the effects of combustible gases on the characteristics of methane explosions is essential to prevent and control methane explosions. FLACS software was used to simulate an explosion of a mixture of CH4 and combustible gases (C2H4, C2H6, and CO) at various mixing concentrations and different temperatures (25, 60, 100, 140 and 180 degrees C). After adding combustible gases to methane at a constant volume and atmospheric pressure, the adiabatic flame temperature linearly increases as the initial temperature increases. Under stoichiometric conditions (9.5% CH4 -air mixture). the addition of C2H4 and C2H6 has a greater effect on the adiabatic flame temperature of methane than H2 and CO at different initial temperatures. Under the fuel-lean CH 4 -air mixture (7% CH4-air mixture) and fuel-rich mixture (11% Ca-air mixture), the addition of H-2 and CO has a greater effect on the adiabatic flame temperature of methane. In contrast, the addition of combustible gases negatively affected the maximum explosion pressure of the CH4 -air mixture, exhibiting a linearly decreasing trend with increasing initial temperature. As the volume fraction of the mixed gas increases, the adiabatic flame temperature and maximum explosion pressure of the stoichiometric conditions increase. In contrast, under the fuel-rich mixture, the combustible gas slightly lowered the adiabatic flame temperature and the maximum explosion pressure. When the initial temperature was 140 C. the fuel consumption time was approximately 8-10 ms earlier than that at the initial temperature of 25=C. When the volume fraction of the combustible gas was 2.0%, the consumption time of fuel reduced by approximately 10 ms compared with that observed when the volume fraction of flammable gas was 0.4%.

Studies of combustible cloud explosion with limited energy release

Numerical simulation of blast generated by unconfined volume cloud explosion

Experimental Investigation into Deflagration of Small-Volume Combustible Vapour Clouds

NUMERICAL SIMULATION INTO DEFLAGRATION-FIELD OF COMBUSTIBLE VAPOUR CLOUD OPENING TO AIR

Experimental and numerical simulation study on the dispersion and explosion process of solid-liquid-air mixed three phase components

Research Progress of Unconfined Vapor Cloud Explosion

Investigation on unconfined hydrogen cloud explosion with external turbulence

A Whole Explosive Dispersion Process Prediction Model for Fuel Clouds

Experimental study on ignition behavior of pulverized coal particle clouds in a turbulent jet

Numerical Investigation on Effects of Ignition Energy on Two-phase Detonation Wave Formation

Pressure waves generated by low steady speed flames traveling in combustible clouds

Combustion and flame characteristics of fuel cloud induced by flow ignition

Experimental Study on the Domino Effect in Explosions Caused by Vertically Distributed Methane/air Vapor Clouds

Thermal and shock dynamics interactions in vapor-liquid two-phase detonation

Evaluation of hydrogen-blended methane explosion

Effect of Volumetric Expansion on Shock-Induced Ignition of H2–NO2/N2O4 Mixtures

Ignition of H2-NO2 & N2O4 Mixtures under Volumetric Expansion Conditions

Combustion and Microexplosion of Freely Falling Multicomponent Droplets

Numerical Simulation on Methane Coal Dust Composite Explosion in Restricted Space by Ultrafine Water Mist Suppression

SIMULATION STUDIES ON THE INFLUENCE OF OTHER COMBUSTIBLE GASES ON THE CHARACTERISTICS OF METHANE EXPLOSIONS AT CONSTANT VOLUME AND HIGH TEMPERATURE

Experimental and numerical study of combustion fireball buoyant vortex rings