Abstract:Vented methane deflagrations in a 1 m3 vessel were investigated.Double flame acceleration phenomena were observed.CFD software FLACS was validated against experimental data.The mechanisms of the external overpressure peaks were revealed.The location of the external explosion was determined.This paper experimentally investigated the effect of low vent burst pressure on the overpressure buildup and flame evolution during the vented methane-air deflagrations in a 1 m3 rectangular vessel. CFD software FLACS was assessed in simulation of vented methane-air explosions against the experiment. Experimental results demonstrate that four overpressure peaks of Popen, Pout, Pext and Pacc from the vent failure, flame venting, external explosion and acoustically enhanced combustion, respectively, were observed except for the free venting case, in which only two overpressure peaks of Pout and Pext were monitored. The flame behaviors corresponding to different overpressure peaks were monitored especially at Pacc, where an abrupt increase in flame luminosity was observed on the bottom of the vessel due to the combustion of pockets of flammable mixture. Popen and Pacc increase with the vent burst pressure while Pout and Pext are nearly independent of the vent burst pressure. Double flame accelerations were observed owing to the vent rupture and flame venting. The phenomena of Helmholtz oscillation and the bulk motion of flame bubble always appeared after the vent rupture. The predicted overpressure agrees reasonably well with the experimental data. The discrepancy of the predicted and measured maximum peak overpressures reduces with increasing vent burst pressure. The predicted maximum peak overpressure and external flame length are slightly larger than those in experiment, which would facilitate the safe design in explosion venting and offer a better guidance in risk assessment. The simulation results also show that two overpressure peaks were recorded resulting from the pressure wave propagating above the vessel and the external explosion, respectively.

Research on Unconfined Vapour Explosion Based on the Little Agitation Theory

Experimental Investigation into Deflagration of Small-Volume Combustible Vapour Clouds

Research Progress of Unconfined Vapor Cloud Explosion

NUMERICAL SIMULATION INTO DEFLAGRATION-FIELD OF COMBUSTIBLE VAPOUR CLOUD OPENING TO AIR

Studies on a Swirling Heptane Spray Flame by Large-Eddy Simulation

Study on dynamic characteristics of cavitation in underwater explosion with large charge

Quantitative Study on the Influence of Bubble Explosion on Evaporation Characteristics of Flash Boiling Spray Using UV-LAS Technique

Studies of combustible cloud explosion with limited energy release

Modeling of Emulsion Droplet Vaporization and Combustion Including Microexplosion Analysis

Experimental research on the venting characteristics of methane and coal dust two-phase system mixture explosions

Influence of Thermal Stratification by Fire on Heat-Mass Coupling Response Mechanism of the Liquefied Tank

Investigation on vented ethanol-gasoline vapor explosion characteristics initiated via single and dual sparks

Explosion-vented Processes for Methane-Air Premixed Gas in Spherical Vessels with Venting Pipes

Experimental Investigation And Numerical Simulation Of Gas Explosion In Linked Vessels

Shock Wave Dynamics and Venting Overpressure Hazards Induced by Indoor Premixed Hydrogen/air Explosion

Investigation on unconfined hydrogen cloud explosion with external turbulence

Experimental and numerical study on the effect of low vent burst pressure on vented methane-air deflagrations

A DESIGN STUDY ON AN AERODYNAMIC LEVITATION SYSTEM FOR DROPLET PREPARATION IN STEAM EXPLOSION EXPERIMENT

Investigation on the Flame Front and Flow Field in Acoustically Excited Swirling Flames with and Without Confinement

Experimental Study of the Effects of Ullage Height on Fire Plume Centerline Temperature with a New Virtual Origin Model

Experiments and modeling of the temperature profile of turbulent diffusion flames with large ullage heights