Abstract:The demand for renewable energy sources, including solar, is increasing every year, stimulating researchers to develop innovative technological solutions for obtaining material for photovoltaic modules - solar silicon. The article discusses a new process for the vapor transport of silicon in the form of sulfide compounds, which can serve as the basis for a halogen-free technology for producing high-purity silicon for photovoltaic batteries. Considering the well-known properties of silicon di- and monosulfide, it is proposed to use zinc sulfide as a carrier reagent, the presence of which in the Si-ZnS system first provides silicon sulfidization with the formation of gaseous products Zn (g) and SiS (g), and then the reduction of monosulfide to elemental silicon. The possibility of a chemical vapor transport reaction of silicon with zinc sulfide at a temperature above 1000 °C and a Si/ZnS ratio of 1 was justified by the method of the thermodynamic simulation of interactions in the Si-ZnS system in the temperature range 500-1500 °C. Based on the obtained equilibrium models of the interaction of zinc sulfide with technical silicon (grade Kr 2), the separation coefficients of (α) silicon from impurity elements that affect the electrophysical properties of silicon, in particular, reduce the lifetime of excess charge carriers, are calculated. The selectivity of this transport reaction and the prospects for its use for refining metallurgical silicon are estimated. It has been shown that the use of the silicon transfer reaction of zinc sulfide, for example, at 1100 °C, can provide deep purification of silicon from Fe, Ca, Ti, V, Cr, Mn and Cu (α ~ 108-1012), as well as Mg and Al (α ~ 104-106). The process is less effective for removing P and B (α ~ 102) and is not applicable for alkali metals in the entire studied temperature range. It is theoretically possible to improve the refining indexes by lowering the reaction temperature, but the necessary sulfur concentration in the gas phase for the complete conversion of silicon to SiS (g) is achieved only above 1050-1100 oC due to thermal dissociation of ZnS.

Research Development on Preparation of Solar Grade Silicon by Alloy Solvent Refining

A High-Efficiency and Energy-Saving Method for Purifying Industrial Silicon for Silicone Use

Study on the Removal of Impurities in Silicon by Electrorefining

The Study of Refining Solanesol by Molecular Distillation

Recent Patenting Activities in Low-Cost Silicon Raw Materials for Silicon Solar Cells

Comparative study on removal of metallurgical silicon impurities by different acid leaching methods

PURIFICATION AND CHARACTERIZATION OF METALLURGICAL GRADE SILICON BY THREE-LAYER ELECTROREFINING

Purification of metallurgical-grade silicon combining Sn–Si solvent refining with gas pressure filtration

Boron Removal from Silicon Using Secondary Refining Techniques by Metallurgical Method

Effect of Si Content on the Morphology Evolution of the Si Primary Dendrites in Al-Si Alloy Solvent Refining Process

Removal of Impurities from Metallurgical Grade Silicon During Ga-Si Solvent Refining

Enhanced separation of bulk silicon from Si-Sn melt via electromagnetic directional solidification

The use of vacuum refining to separate Ca, Al, and P from crude metallurgical grade silicon

Low-cost solar grade silicon purification process with Al–Si system using a powder metallurgy technique

Analysis Pollutant Production and Discharge in high-purity polysilicon industry of solar cell

Toward sustainability for upcycling SoG-Si scrap by an immersion rotational segregation purification process

Silicon prepared by electro-reduction in molten salts as new energy materials

Influence of Iron, Aluminum, Calcium, Titanium and Vanadium Impurities Removal from Silicon Based on Cu-catalyzed Chemical Leaching

A comprehensive hydrometallurgical recycling approach for the environmental impact mitigation of EoL solar cells

Assessment of silicon purification possibility by chemical vapor transport reaction with zinc sulfide

Purification of Organosilicon Waste Silicon Powder with Hydrometallurgy